Skip to main content
main-content

Tipp

Weitere Artikel dieser Ausgabe durch Wischen aufrufen

Erschienen in: Emission Control Science and Technology 3/2019

15.07.2019 | Original Paper

A New Periodic Technical Inspection for Particle Emissions of Vehicles

verfasst von: H. Burtscher, Th. Lutz, A. Mayer

Erschienen in: Emission Control Science and Technology | Ausgabe 3/2019

Einloggen, um Zugang zu erhalten
share
TEILEN

Abstract

Meanwhile, a high fraction of vehicles, driven by diesel engines, is equipped with very efficient particle filters in Europe. The filters have been enforced by the particle number limit for type approval testing. If the filter works properly, the emissions are very low. However, a small fraction of vehicles having broken or manipulated particle filters and therefore very high emissions can dominate the average fleet emissions of vehicles. The on-board diagnostic systems do not detect most of these filter defects. In several studies, failure rates in the order of some percent up to 20% have been observed. Therefore, identifying these high polluters is urgently needed. An option to achieve this is a periodical technical inspection. Gasoline engines may also have very high particle emissions, if there is a malfunction. Nevertheless, as a first step, the focus of current work is on diesel engines. Some data for gasoline engines will be presented, but the suggested test procedure has only been verified for diesel engines. For these, it has been shown that a test measurement can be done at low idle, which allows a fast and cheap procedure. Requirements for the test instrumentation are specified and a test procedure is suggested. A limit value is proposed which on the one hand is higher than requirements in type approval, but low enough to detect high polluters. The method suggested can be applied to passenger vehicles, as well as to heavy-duty engines and off-road applications.
Literatur
1.
Zurück zum Zitat Kurniawan, A., Schmidt-Ott, A.: Monitoring the soot emissions of passing cars. Environ. Sci. Technol. 40(6), 1911–1915 (2006) CrossRef Kurniawan, A., Schmidt-Ott, A.: Monitoring the soot emissions of passing cars. Environ. Sci. Technol. 40(6), 1911–1915 (2006) CrossRef
2.
Zurück zum Zitat Saliba, G., Saleh, R., Zhao, Y., Presto, A., Lambe, A.T., Frodin, B., Sardar, S., Maldo-nado, H., Maddox, C.H., May, A.A., Drozd, G.T., Goldstein, A.H., Russell, L.M., Hagen, F., Robinson, A.L.: Comparison of gasoline direct-injection (GDI) and port fuel injection (PFI) vehicle emissions: emission certification standards, cold-start, secondary organic aerosol formation potential, and potential climate impacts. Environ. Sci. Technol. 51, 6542–6552 (2017) CrossRef Saliba, G., Saleh, R., Zhao, Y., Presto, A., Lambe, A.T., Frodin, B., Sardar, S., Maldo-nado, H., Maddox, C.H., May, A.A., Drozd, G.T., Goldstein, A.H., Russell, L.M., Hagen, F., Robinson, A.L.: Comparison of gasoline direct-injection (GDI) and port fuel injection (PFI) vehicle emissions: emission certification standards, cold-start, secondary organic aerosol formation potential, and potential climate impacts. Environ. Sci. Technol. 51, 6542–6552 (2017) CrossRef
3.
Zurück zum Zitat Czerwinski, J., Comte, P., Engelmann, D., Heeb, N., Muñoz, M., Bonsack, P., Hensel, V., May-er, A.: PN-emissions of gasoline cars MPI and potentials of GPF SAE technical paper 2018–.1–0363 (2018) Czerwinski, J., Comte, P., Engelmann, D., Heeb, N., Muñoz, M., Bonsack, P., Hensel, V., May-er, A.: PN-emissions of gasoline cars MPI and potentials of GPF SAE technical paper 2018–.1–0363 (2018)
5.
Zurück zum Zitat Zhang, Q., Jimenez, J.L., Canagaratna, M.R., Allan, J.D., Coe, H., Ulbrich, I., Alfarra, M.R., Takami, A., Middlebrook, A.M., Sun, Y.L., Dzepina, K., Dunlea, E., Docherty, K., DeCarlo, P.F., Salcedo, D., Onasch, T., Jayne, J.T., Miyoshi, T., Shimono, A., Hatakeyama, S., Takegawa, N., Kondo, Y., Schneider, J., Drewnick, F., Borrmann, S., Weimer, S., Demerjian, K., Williams, P., Bower, K., Bahreini, R., Cottrell, L., Griffin, R.J., Rautiainen, J., Sun, J.Y., Zhang, Y.M., Worsnop, D.R.: Ubiquity and dominance of oxygenated species in organic aerosols in anthropogenically-influenced Northern Hemisphere midlatitudes. Geophys. Res. Lett. 34, L13801 (2007) Zhang, Q., Jimenez, J.L., Canagaratna, M.R., Allan, J.D., Coe, H., Ulbrich, I., Alfarra, M.R., Takami, A., Middlebrook, A.M., Sun, Y.L., Dzepina, K., Dunlea, E., Docherty, K., DeCarlo, P.F., Salcedo, D., Onasch, T., Jayne, J.T., Miyoshi, T., Shimono, A., Hatakeyama, S., Takegawa, N., Kondo, Y., Schneider, J., Drewnick, F., Borrmann, S., Weimer, S., Demerjian, K., Williams, P., Bower, K., Bahreini, R., Cottrell, L., Griffin, R.J., Rautiainen, J., Sun, J.Y., Zhang, Y.M., Worsnop, D.R.: Ubiquity and dominance of oxygenated species in organic aerosols in anthropogenically-influenced Northern Hemisphere midlatitudes. Geophys. Res. Lett. 34, L13801 (2007)
6.
Zurück zum Zitat Giechaskiel, B., Dilara, P., Andersson, J.: Particle measurement programme (PMP) light-duty inter-laboratory exercise: repeatability and reproducibility of the particle number method. Aerosol Sci. Technol. 42(7), 528–543 (2008) CrossRef Giechaskiel, B., Dilara, P., Andersson, J.: Particle measurement programme (PMP) light-duty inter-laboratory exercise: repeatability and reproducibility of the particle number method. Aerosol Sci. Technol. 42(7), 528–543 (2008) CrossRef
9.
Zurück zum Zitat Bundesministerium für Verkehr und digitale Infrastruktur: Änderung der Richtlinie für die Durchführung der Untersuchung der Abgase von Kraftfahrzeugen nach Nummer 6.8.2 der Anlage VIIIa Straßenverkehrs-Zulassungs- Ordnung (StVZO) (AU- Richtlinie), Bonn, Germany, Verkehrsblatt 2, 19, 2017 K4431A (2017) Bundesministerium für Verkehr und digitale Infrastruktur: Änderung der Richtlinie für die Durchführung der Untersuchung der Abgase von Kraftfahrzeugen nach Nummer 6.8.2 der Anlage VIIIa Straßenverkehrs-Zulassungs- Ordnung (StVZO) (AU- Richtlinie), Bonn, Germany, Verkehrsblatt 2, 19, 2017 K4431A (2017)
10.
Zurück zum Zitat Kadijk, G., Elstgeest, M., Ligterink, N.E., van der Mark, P.J.: Investigation into a periodic technical inspection (PTI) test method to check for presence and proper functioning of diesel particulate filters in light-duty diesel vehicles – part 2. Report TNO 2017 R10530, (2017) Kadijk, G., Elstgeest, M., Ligterink, N.E., van der Mark, P.J.: Investigation into a periodic technical inspection (PTI) test method to check for presence and proper functioning of diesel particulate filters in light-duty diesel vehicles – part 2. Report TNO 2017 R10530, (2017)
11.
Zurück zum Zitat Giechaskiel, B., Lahde, T., Suarez-Bertoa, R., Clairotte, M., Grigoratos, T., Zardini, A., Perujo, A., Martini, G.: Particle number measurements in the European legislation and future JRC activities (CE-2018-301). Combustion Engines. 174, 3–16 (2018) Giechaskiel, B., Lahde, T., Suarez-Bertoa, R., Clairotte, M., Grigoratos, T., Zardini, A., Perujo, A., Martini, G.: Particle number measurements in the European legislation and future JRC activities (CE-2018-301). Combustion Engines. 174, 3–16 (2018)
14.
Zurück zum Zitat Kadijk, G., Spreen, J.S., van der Mark, P.J.: Investigation into a periodic technical inspection test method to check for presence and proper functioning of diesel particulate filters in light-duty diesel vehicles. Report TNO 2016 R10735v2 (2016) Kadijk, G., Spreen, J.S., van der Mark, P.J.: Investigation into a periodic technical inspection test method to check for presence and proper functioning of diesel particulate filters in light-duty diesel vehicles. Report TNO 2016 R10735v2 (2016)
16.
Zurück zum Zitat Nauroy, H., Compte, P., Czerwinski, J., Willi, P.: Field Particle Number and Opacity Measurements on Construction Machinery. Report Berner Fachhochschule, Labor für Verbrennungsmotoren und Abgastechnik (2017) Nauroy, H., Compte, P., Czerwinski, J., Willi, P.: Field Particle Number and Opacity Measurements on Construction Machinery. Report Berner Fachhochschule, Labor für Verbrennungsmotoren und Abgastechnik (2017)
17.
Zurück zum Zitat Demski, M.: 10 th vert forum: best available technology for in-use and OE-engines, Empa Dübendorf, March 14, (2019) Demski, M.: 10 th vert forum: best available technology for in-use and OE-engines, Empa Dübendorf, March 14, (2019)
18.
Zurück zum Zitat VERT https://​www.​vert-dpf.​eu VERT https://​www.​vert-dpf.​eu
20.
Zurück zum Zitat Burtscher, H.: Physical characterization of particulate emissions from diesel engines: a review. J. Aerosol Sci. 36(7), 896–932 (2005) CrossRef Burtscher, H.: Physical characterization of particulate emissions from diesel engines: a review. J. Aerosol Sci. 36(7), 896–932 (2005) CrossRef
21.
Zurück zum Zitat Swanson, J., Kittelson, D.: Evaluation of thermal denuder and catalytic stripper methods for solid particle measurements. J. Aerosol Sci. 41(12), 1113–1122 (2010) CrossRef Swanson, J., Kittelson, D.: Evaluation of thermal denuder and catalytic stripper methods for solid particle measurements. J. Aerosol Sci. 41(12), 1113–1122 (2010) CrossRef
22.
Zurück zum Zitat Cheng, Y.C.: Condensation particle counters. In: Kulkarni, P., Baron, P.A., Willeke, K. (eds.) Aerosol Measurement: Principles, Techniques, and Applications. pp. 381–392. John Wiley & Sons, (2011) Cheng, Y.C.: Condensation particle counters. In: Kulkarni, P., Baron, P.A., Willeke, K. (eds.) Aerosol Measurement: Principles, Techniques, and Applications. pp. 381–392. John Wiley & Sons, (2011)
23.
Zurück zum Zitat Fierz, M., Houle, C., Steigmeier, P., Burtscher, H.: Design, calibration and field performance of a miniature diffusion size classifier. Aerosol Sci. Technol. 45(1), 1–10 (2011) CrossRef Fierz, M., Houle, C., Steigmeier, P., Burtscher, H.: Design, calibration and field performance of a miniature diffusion size classifier. Aerosol Sci. Technol. 45(1), 1–10 (2011) CrossRef
24.
Zurück zum Zitat Fierz, M., Meier, D., Steigmeier, P., Burtscher, H.: Aerosol measurements by induced currents. Aerosol Sci. Technol. 48(4), 350–357 (2014) CrossRef Fierz, M., Meier, D., Steigmeier, P., Burtscher, H.: Aerosol measurements by induced currents. Aerosol Sci. Technol. 48(4), 350–357 (2014) CrossRef
25.
Zurück zum Zitat Schriefl, M.A., Bergmann, A., Fierz, M.: Design principles for sensing particle number concentration and mean particle size with unipolar diffusion charging. IEEE Sensors J. 19(4), 1392–1399 (2019) CrossRef Schriefl, M.A., Bergmann, A., Fierz, M.: Design principles for sensing particle number concentration and mean particle size with unipolar diffusion charging. IEEE Sensors J. 19(4), 1392–1399 (2019) CrossRef
26.
Zurück zum Zitat Papaioannou, E., Zarvalis, D., Melas, A. D., Baltzopoulou, P., Konstandopoulos, A.G., Zamora, D., Burtscher, H., Fierz, M.: The SUREAL-23 project: understanding and measuring Sub-23 nm particle emissions from direct injection engines. Conference: EARPA future of road mobility forum (FORM forum 2018), session “research with impact”, Proceedings, p. 41–50, 17 October (2018) Papaioannou, E., Zarvalis, D., Melas, A. D., Baltzopoulou, P., Konstandopoulos, A.G., Zamora, D., Burtscher, H., Fierz, M.: The SUREAL-23 project: understanding and measuring Sub-23 nm particle emissions from direct injection engines. Conference: EARPA future of road mobility forum (FORM forum 2018), session “research with impact”, Proceedings, p. 41–50, 17 October (2018)
28.
Zurück zum Zitat Amanatidis, S., Maricq, M.M., Ntziachristos, N., Samaras, Z.: Application of the dual Pegasor particle sensor to real-time measurement of motor vehicle exhaust PM. J. Aerosol Sci. 103, 93–104 (2017) CrossRef Amanatidis, S., Maricq, M.M., Ntziachristos, N., Samaras, Z.: Application of the dual Pegasor particle sensor to real-time measurement of motor vehicle exhaust PM. J. Aerosol Sci. 103, 93–104 (2017) CrossRef
29.
Zurück zum Zitat Maricq, M.M., Bilby, D.: The impact of voltage and flow on the electrostatic soot sensor and the implications for its use as a diesel particulate filter monitor. J. Aerosol Sci. 124, 41–53 (2018) CrossRef Maricq, M.M., Bilby, D.: The impact of voltage and flow on the electrostatic soot sensor and the implications for its use as a diesel particulate filter monitor. J. Aerosol Sci. 124, 41–53 (2018) CrossRef
30.
Zurück zum Zitat Hinds, W.C.: Aerosol Technology, Properties, Behavior, and Measurement of Airborne Particles. Wiley, New York (1999) Hinds, W.C.: Aerosol Technology, Properties, Behavior, and Measurement of Airborne Particles. Wiley, New York (1999)
31.
Zurück zum Zitat Mamakos, A., Khalek, I., Giannelli, R., Matthe Spears, M.: Characterization of combustion aerosol produced by a mini-CAST and treated in a catalytic stripper. Aerosol Sci. Technol. 47(8), 927–936 (2013) CrossRef Mamakos, A., Khalek, I., Giannelli, R., Matthe Spears, M.: Characterization of combustion aerosol produced by a mini-CAST and treated in a catalytic stripper. Aerosol Sci. Technol. 47(8), 927–936 (2013) CrossRef
33.
Zurück zum Zitat Luftreinhalte-Verordnung 814.318.142.1, admin.ch Luftreinhalte-Verordnung 814.318.142.1, admin.ch
34.
Zurück zum Zitat Schmid, O., Stoege, T.: Surface area is the biologically most effective dose metric for acute nanoparticle toxicity in the lung. J. Aerosol Sci. 99, 133–143 (2016) CrossRef Schmid, O., Stoege, T.: Surface area is the biologically most effective dose metric for acute nanoparticle toxicity in the lung. J. Aerosol Sci. 99, 133–143 (2016) CrossRef
35.
Zurück zum Zitat Schindler, W., Haisch, C., Beck, H.A., Niessner, R., Jacob, E., Rothe, D.: A Photoacoustic Sensor System for Time Resolved Quantification of Diesel Soot Emissions, pp. 2004–01-0968. SAE International (2004) Schindler, W., Haisch, C., Beck, H.A., Niessner, R., Jacob, E., Rothe, D.: A Photoacoustic Sensor System for Time Resolved Quantification of Diesel Soot Emissions, pp. 2004–01-0968. SAE International (2004)
36.
Zurück zum Zitat Kadijk, G., Elstgeest, M., Ligterink, N.E., van der Mark, P.J.: Emissions of twelve petrol vehicles with high mileages. TNO report TNO 2018 R11114 (2018b) Kadijk, G., Elstgeest, M., Ligterink, N.E., van der Mark, P.J.: Emissions of twelve petrol vehicles with high mileages. TNO report TNO 2018 R11114 (2018b)
Metadaten
Titel
A New Periodic Technical Inspection for Particle Emissions of Vehicles
verfasst von
H. Burtscher
Th. Lutz
A. Mayer
Publikationsdatum
15.07.2019
Verlag
Springer International Publishing
Erschienen in
Emission Control Science and Technology / Ausgabe 3/2019
Print ISSN: 2199-3629
Elektronische ISSN: 2199-3637
DOI
https://doi.org/10.1007/s40825-019-00128-z

Weitere Artikel der Ausgabe 3/2019

Emission Control Science and Technology 3/2019 Zur Ausgabe

Special Issue: 2018 CLEERS Workshop, September 18-20, Ann Arbor, Michigan, United States

Model-Based Analysis of TWC-Coated Filters Performance

Special Issue: 2018 CLEERS Workshop, September 18-20, Ann Arbor, Michigan, United States

Effect of Reductants on the NOx Storage Performance of a Pd/CZO Low Temperature NOx Adsorber

Special Issue: 2018 CLEERS Workshop, September 18-20, Ann Arbor, Michigan, United States

Passive SCR Performance Under Pseudo-Transient Cycle: Challenges and Opportunities for Meeting Tier 3 Emissions

Special Issue: 2018 CLEERS Workshop, September 18-20, Ann Arbor, Michigan, United States

Impacts of Air-Fuel Stratification in ACI Combustion on Particulate Matter and Gaseous Emissions

Stellenausschreibungen

Anzeige

Premium Partner