Top

Published in:

09-04-2019 | Original

Wood residue reuse for a synthesis of lignocellulosic biosorbent: characterization and application for simultaneous removal of copper (II), Reactive Blue 19 and cyprodinil from water

Authors: Nena Velinov, Jelena Mitrović, Miloš Kostić, Miljana Radović, Milica Petrović, Danijela Bojić, Aleksandar Bojić

Published in: Wood Science and Technology | Issue 3/2019

Activate our intelligent search to find suitable subject content or patents.

search-config

AI-assisted search

Off

Abstract

A new lignocellulosic-Al₂O₃ hybrid biosorbent (LC-Al₂O₃) was synthesized using wood residue material from the oak tree (Quercus robur). Biosorbent was tested for the simultaneous removal of three different types of pollutants: cationic (copper (II) ions), anionic (textile dye Reactive Blue 19) and nonpolar (fungicide cyprodinil) in the multi-component model solution and natural water. Biosorbent characterization was performed by Fourier transform infrared spectroscopy, scanning electron microscopy with energy-dispersive X-ray spectroscopy (SEM–EDX) and X-ray diffraction analysis. In order to define optimal process parameters for simultaneous removal of all three pollutants, effects of pH, temperature, sorbent dose, pollutants concentration and hydrodynamic conditions on the sorption process were investigated. Sorption of pollutants onto LC-Al₂O₃ was highly pH-dependent and the optimal pH is 5, with removal efficiency near 98% for all three pollutants. Sorption kinetics followed pseudo-second-order, intraparticle diffusion and Chrastil’s models, which suggest that both surface reaction and diffusion were rate-limiting steps. Equilibrium experimental results are the best fitted by the Langmuir sorption isotherm model. The maximal sorption capacities of the biosorbent for simultaneous removal of pollutants in multi-component system are 15.69 mg g⁻¹ for copper (II), 29.99 mg g⁻¹ for Reactive Blue 19 and 20.97 mg g⁻¹ for cyprodinil. The present study shows that using wood residue material to produce a low-cost sorbent can reduce wood waste and increase reuse/recycling options, and also effectively decrease the water pollution simultaneously removing heavy metal ion, textile dye and pesticide from aqueous model solution and contaminated river water.

previous article Comparison of pyrolyzed lignin before and after milled wood lignin purification of Norway spruce with increasing steam explosion

next article Preparation of graphene oxide and alkali lignin nanohybrids and its application to reinforcing polymer

Dont have a licence yet? Then find out more about our products and how to get one now:

Springer Professional "Technik"

Online-Abonnement

Mit Springer Professional "Technik" erhalten Sie Zugriff auf:

über 67.000 Bücher
über 390 Zeitschriften

aus folgenden Fachgebieten:

Automobil + Motoren
Bauwesen + Immobilien
Business IT + Informatik
Elektrotechnik + Elektronik
Energie + Nachhaltigkeit
Maschinenbau + Werkstoffe

Jetzt Wissensvorsprung sichern!

inform now

Springer Professional "Wirtschaft+Technik"

Online-Abonnement

Mit Springer Professional "Wirtschaft+Technik" erhalten Sie Zugriff auf:

über 102.000 Bücher
über 537 Zeitschriften

aus folgenden Fachgebieten:

Automobil + Motoren
Bauwesen + Immobilien
Business IT + Informatik
Elektrotechnik + Elektronik
Energie + Nachhaltigkeit
Finance + Banking
Management + Führung
Marketing + Vertrieb
Maschinenbau + Werkstoffe
Versicherung + Risiko

Jetzt Wissensvorsprung sichern!

inform now

Available only for authorised users

Abdolali A, Ngo HH, Guo W, Zhou JL, Du B, Wei Q, Wang XC, Nguyen PD (2015) Characterization of a multi-metal binding biosorbent: chemical modification and desorption studies. Bioresour Technol 193:477–487CrossRefPubMed

Akbari M, Hallajisani A, Keshtkar AR, Shahbeig H, Ghorbanian SA (2015) Equilibrium and kinetic study and modeling of Cu(II) and Co(II) synergistic biosorption from Cu(II)-Co(II) single and binary mixtures on brown algae C. indica. J Environ Chem Eng 3:140–149CrossRef

Aksu Z, Akpınar D (2000) Modelling of simultaneous biosorption of phenol and nickel(II) onto dried aerobic activated sludge. Sep Purif Technol 21(1–2):87–99CrossRef

Albadarin AB, Solomon S, Kurniawan TA, Mangwandi C, Walker G (2017) Single, simultaneous and consecutive biosorption of Cr(VI) and Orange II onto chemically modified masau stones. J Environ Manag 204:365–374CrossRef

Albert Q, Leleyter L, Lemoine M, Heutte N, Rioult J-P, Sage L, Baraud F, Garon D (2018) Comparison of tolerance and biosorption of three trace metals (Cd, Cu, Pb) by the soil fungus Absidia cylindrospora. Chemosphere 196:386–392CrossRefPubMed

Alqadami AA, Naushad M, Alothman ZA, Ghfar AA (2017) Novel metal-organic framework (MOF) based composite material for the sequestration of U(VI) and Th(IV) metal ions from aqueous environment. ACS Appl Mater Interfaces 9:36026–36037CrossRefPubMed

Alqadami AA, Naushad M, Alothman ZA, Ahamad T (2018) Adsorptive performance of MOF nanocomposite for methylene blue and malachite green dyes: kinetics, isotherm and mechanism. J Environ Manage 223:29–36CrossRefPubMed

Amirnia S, Ray MB, Margaritis A (2016) Copper ion removal by Acer saccharum leaves in a regenerable continuous-flow column. Chem Eng J 287:755–764CrossRef

Anandkumar J, Mandal B (2011) Adsorption of chromium(VI) and Rhodamine B by surface modified tannery waste: kinetic, mechanistic and thermodynamic studies. J Hazard Mater 186:1088–1096CrossRefPubMed

Araghi SH, Entezari MH (2015) Amino-functionalized silica magnetite nanoparticles for the simultaneous removal of pollutants from aqueous solution. Appl Surf Sci 333:68–77CrossRef

Ayoob S, Gupta AK, Bhakat PB, Bhat VT (2007) Investigations on the kinetics and mechanisms of sorptive removal of fluoride from water using alumina cement granules. Chem Eng J 140:6–14CrossRef

Bektaş N, Aydın S, Öncel MS (2011) The adsorption of arsenic ions using beidellite, zeolite, and sepiolite clays: a study of kinetic, equilibrium and thermodynamics. Sep Sci Technol 46:1005–1016CrossRef

Berrazoum A, Marouf R, Ouadjenia F, Schott J (2015) Bioadsorption of a reactive dye from aqueous solution by municipal solid waste. Biotechnol Rep 7:44–50CrossRef

Bozbas SK, Boz Y (2016) Low-cost biosorbent: anadara inaequivalvis shells for removal of Pb(II) and Cu(II) from aqueous solution. Process Saf Environ Prot 103:144–152CrossRef

Chaudhuri H, Dash S, Ghorai S, Pal S, Sarkar A (2016) SBA-16: application for the removal of neutral, cationic, and anionic dyes from aqueous medium. J Environ Chem Eng 4:157–166CrossRef

Chrastil J (1990) Adsorption of direct dyes on cotton: kinetics of dyeing from finite baths based on new information. Text Res J 60:413–416CrossRef

Daneshvar E, Vazirzadeh A, Niazi A, Kousha M, Naushad M, Bhatnagar A (2017) Desorption of methylene blue dye from brown macroalga: effects of operating parameters, isotherm study and kinetic modeling. J Clean Prod 152:443–453CrossRef

Deng JH, Zhang XR, Zeng GM, Gong JL, Niu QY, Liang J (2013) Simultaneous removal of Cd (II) and ionic dyes from aqueous solution using magnetic graphene oxide nanocomposite as an adsorbent. Chem Eng J 226:189–200CrossRef

El-Sakhawy M (2001) Characterization of modified oxycellulose. J Therm Anal Cal 63:549–558CrossRef

Entezari MH, Soltani T (2008) Simultaneous removal of copper and lead ions from a binary solution by sono-sorption process. J Hazard Mater 160:88–93CrossRefPubMed

Freundlich HZ (1906) Over the adsorption in solution. J Phys Chem 57A:385–470

Ho YS, McKay G (1998) Kinetic models for the sorption of dye from aqueous solution by wood. Process Saf Environ Prot 76:183–191CrossRef

Ho YS, McKay G (2000) The kinetics of sorption of divalent metal ions onto sphagnum moss peat. Water Res 34:735–742CrossRef

Huang L, Zhou Y, Guo X, Chen Z (2015) Simultaneous removal of 2,4-dichlorophenol and Pb(II) from aqueous solution using organoclays: isotherm, kinetics and mechanism. J Ind Eng Chem 22:280–287CrossRef

Huang L, He M, Chen B, Hu B (2018) Magnetic Zr–MOFs nanocomposites for rapid removal of heavymetal ions and dyes fromwater. Chemosphere 199:435–444CrossRefPubMed

Isah AU, Abdulraheem G, Bala S, Muhammad S, Abdullahi M (2015) Kinetics, equilibrium and thermodynamics studies of C.I. Reactive Blue 19 dye adsorption on coconut shell based activated carbon. Int Biodeterior Biodegrad 102:265–273CrossRef

Javadian H, Angaji MT, Naushad M (2014) Synthesis and characterization of polyaniline/γ-alumina nanocomposite: a comparative study for the adsorption of three different anionic dyes. J Ind Eng Chem 20:3890–3900CrossRef

Jin X, Zha S, Li S, Chen Z (2014) Simultaneous removal of mixed contaminants by organoclays—amoxicillin and Cu(II) from aqueous solution. Appl Clay Sci 102:196–201CrossRef

Jin X, Zheng M, Sarkar B, Naidu R, Chen Z (2016) Characterization of bentonite modified with humic acid for the removal of Cu (II) and 2,4-dichlorophenol from aqueous solution. Appl Clay Sci 134:89–94CrossRef

Kallel F, Bouaziz F, Chaari F, Belghith L, Ghorbel R, Chaabouni SE (2016) Interactive effect of garlic straw on the sorption and desorption of Direct Red 80 from aqueous solution. Process Saf Environ Prot 102:30–43CrossRef

Kumar PM, Balasubramanian C, Sali ND, Bhoraskar SV, Rohatgi VK, Badrinarayanan S (1999) Nanophase alumina synthesis in thermal arc plasma and characterization: correlation to gas-phase studies. Mater Sci Eng, B 63:215–227CrossRef

Kyzas GZ, Lazaridis NK, Kostoglou M (2013) On the simultaneous adsorption of a reactive dye and hexavalent chromium from aqueous solutions onto grafted chitosan. J Colloid Interface Sci 407:432–441CrossRefPubMed

Lagergren S (1898) Zur Theorie der sogenannten Adsorption gelöster Stoffe (About the theory of so-called adsorption of soluble substances). Kungliga Svenska Vetenskapsakademiens Handl 24:1–39

Langmuir I (1918) The adsorption of gases on plane surfaces of glass, mica and platinum. J Am Chem Soc 40:1361–1403CrossRef

Lazar T (2005) Color chemistry: synthesis, properties, and applications of organic dyes and pigments. Wiley Online Library, New York

Leodopoulos C, Doulia D, Gimouhopoulos K, Triantis TM (2012) Single and simultaneous adsorption of methyl orange and humic acid onto bentonite. App Clay Sci 70:84–90CrossRef

Li K, Li P, Cai J, Xiao S, Yang H, Li A (2016) Efficient adsorption of both methyl orange and chromium from their aqueous mixtures using a quaternary ammonium salt modified chitosan magnetic composite adsorbent. Chemosphere 154:310–318CrossRefPubMed

Liu Y (2006) Some consideration on the Langmuir isotherm equation. Colloid Surface A 274:34–36CrossRef

Liu Y (2009) Is the free energy change of adsorption correctly calculated? J Chem Eng Data 54:1981–1985CrossRef

Liu Y, Liu K, Zhang L, Zhang Z (2015) Removal of Rhodamine B from aqueous solution using magnetic NiFe nanoparticles. Water Sci Technol 72:1243–1249CrossRefPubMed

Ma L, Chen Q, Zhu J, Xi Y, He H, Zhu R, Tao Q, Ayoko GA (2016a) Adsorption of phenol and Cu(II) onto cationic and zwitterionic surfactant modified montmorillonite in single and binary systems. Chem Eng J 283:880–888CrossRef

Ma L, Zhu J, Xi Y, Zhu R, He H, Liang X, Ayoko GA (2016b) Adsorption of phenol, phosphate and Cd(II) by inorganic–organic montmorillonites: a comparative study of single and multiple solute. Colloids Surf A 497:63–71CrossRef

Naushad M, Abdullah ALOthman Z, Rabiul Awual M, Alfadul SM, Ahamad T (2015) Adsorption of rose Bengal dye from aqueous solution by amberlite Ira-938 resin: kinetics, isotherms, and thermodynamic studies. Desalin Water Treat 57:13527–13533CrossRef

Naushad M, Ahamad T, Al-Maswari BM, Alqadami AA, Alshehri SM (2017) Nickel ferrite bearing nitrogen-doped mesoporous carbon as efficient adsorbent for the removal of highly toxic metal ion from aqueous medium. Chem Eng J 330:1351–1360CrossRef

Oyanedel-Craver VA, Fuller M, Smith JA (2007) Simultaneous sorption of benzene and heavy metals onto two organoclays. J Colloid Interface Sci 309(2):485–492CrossRefPubMed

Pettersen RC (1984) The chemistry of solid wood. Advances in chemistry. Chapter 2: the chemical composition of wood. American Chemical Society, Washington, DC

Pionke HB, Glotfelty DW (1990) Contamination of groundwater by atrazine and selected metabolites. Chemosphere 21:813–822CrossRef

Roonasi P, Nezhad AY (2016) A comparative study of a series of ferrite nanoparticles as heterogeneous catalysts for phenol removal at neutral pH. Mater Chem Phys 172:143–149CrossRef

Santos SCR, Boaventura RAR (2016) Adsorption of cationic and anionic azo dyes on sepiolite clay: equilibrium and kinetic studies in batch mode. J Environ Chem Eng 4:1473–1483CrossRef

Shakib F, Koohi AD, Pirzaman AK (2017) Adsorption of methylene blue by using novel chitosan-g-itaconic acid/bentonite nanocompositeequilibrium and kinetic study. Water Sci Technol 75:1932–1943CrossRefPubMed

Shi Z, Xu C, Guan H, Li L, Fan L, Wang Y, Liu L, Meng Q, Zhang R (2018) Magnetic metal organic frameworks (MOFs) composite for removal of lead and malachite green in wastewater. Colloids Surf. A Physicochem. Eng. Asp. 539:382–390CrossRef

Sips R (1948) On the structure of a catalyst surface. J Chem Phys 16:490–495CrossRef

Sun Y-X, Li X-R, Zhao Y-Y, Li C-Y, Ren Z-L (2014) Simultaneous sorption of Cd²⁺ and phenol to CTMAB-CA modified bentonite from aqueous solutions. Adv Appl Sci Res 5:155–158

Tang WW, Zeng GM, Gong JL, Liu Y, Wang XY, Liu YY, Liu ZF, Chen L, Zhang XR, Tu DZ (2012) Simultaneous adsorption of atrazine and Cu (II) from wastewater by magnetic multi-walled carbon nanotube. Chem Eng J 211:470–478CrossRef

Todorciuc T, Bulgariu L, Popa IV (2015) Adsorption of Cu(II) from aqueous solution on wheat straw lignin: equilibrium and kinetic studies. Cell Chem Technol 49:439–447

Tural B, Ertaş E, Enez B, Fincan SA, Tural S (2017) Preparation and characterization of a novel magnetic biosorbent functionalized with biomass of Bacillus Subtilis: kinetic and isotherm studies of biosorption processes in the removal of Methylene Blue. J Environ Chem Eng 5:4795–4802CrossRef

Vaquero-Fernández L, Sáenz-Hernáez A, Sanz-Asensio J, Fernández-Zurbano P, Sainz-Ramírez M, Pons-Jubera B, López-Alonso M, Epifanio-Fernández S-I, Martínez-Soria M-T (2008) Determination of cyprodinil and fludioxonil in the fermentative process of must by high-performance liquid chromatography-diode array detection. J Sci Food Agric 88:1943–1948CrossRef

Vázquez-Guerrero A, Alfaro-Cuevas-Villanueva R, Rutiaga-Quiñones JG, Cortés-Martínez R (2016) Fluoride removal by aluminum-modified pine sawdust: effect of competitive ions. Ecol Eng 94:365–379CrossRef

Wang W, Tian G, Zhang Z, Wang A (2015) A simple hydrothermal approach to modify palygorskite for high-efficient adsorption of methylene blue and Cu(II) ions. Chem Eng J 265:228–238CrossRef

Weber WJ Jr, Morris JC (1964) Kinetics of adsorption on carbon from solution. J Sanit Eng Div 89:31–60

Wibowo E, Rokhmat M, Sutisna Khairurrijal K, Abdullah M (2017) Reduction of seawater salinity by natural zeolite (Clinoptilolite): adsorption isotherms, thermodynamics and kinetics. Desalination 409:146–156CrossRef

Title: Wood residue reuse for a synthesis of lignocellulosic biosorbent: characterization and application for simultaneous removal of copper (II), Reactive Blue 19 and cyprodinil from water
Authors: Nena Velinov
Jelena Mitrović
Miloš Kostić
Miljana Radović
Milica Petrović
Danijela Bojić
Aleksandar Bojić
Publication date: 09-04-2019
Publisher: Springer Berlin Heidelberg
Published in: Wood Science and Technology / Issue 3/2019
Print ISSN: 0043-7719
Electronic ISSN: 1432-5225
DOI: https://doi.org/10.1007/s00226-019-01093-0

Near-infrared-based models for lignin syringyl/guaiacyl ratio of Eucalyptus benthamii and E. pellita using a streamlined thioacidolysis procedure as the reference method

Original

Preparation of graphene oxide and alkali lignin nanohybrids and its application to reinforcing polymer

Original

IAWS news

IAWS News

Effect of micro-pit texture parameters on characteristics of friction between cemented carbide and wood

Original

Effect of molecular weight of urea–formaldehyde resins on their cure kinetics, interphase, penetration into wood, and adhesion in bonding wood

Original

Effect of methyltrimethoxysilane impregnation on the cell wall porosity and water vapour sorption of archaeological waterlogged oak

Open Access
Original