Abstract
The precipitation of the γ’ (Ll2) and γ" (DO22) phases has been studied in four alloys Fe-Ni-Cr-Ti-Al-Nb containing a higher Ti + Al/Nb ratio than that of the INCONEL 718 alloy. For these alloys, the precipitation microstructure varies rapidly with aging temperature and composition. Bct γ"particles have always been found to precipitate on γ’ phase. Moreover, by aging three alloys above a critical temperature, a “compact ntorphology” has been observed: cube-shaped γ’ particles coated on their six faces with a shell of γ" precipitate. This microstructure has proved to be very stable on prolonged aging. A thermal stability better than that encountered in nominal INCONEL 718 alloy can thus be achieved. The influence of composition and aging temperature on the conditions that bring about this “compact morphology” has been investigated. A minimal Ti + Al/Nb ratio between 0.9 and 1 has been determined, allowing the “compact morphology” to be obtained.
Similar content being viewed by others
References
D. F. Paulonis, J. M. Oblak, and D. S. Duvall:Trans. ASM, 1969, vol. 62, p. 611.
I. Kirman and D. H. Warrington:J. Inst. Metals, 1971, vol. 99, p. 197.
0. H. Kriege and J. M. Baris:Trans. ASM, 1969, vol. 62, p. 195.
H. L. Eiseilstein:Amer. Soc. Testing Mater., Spec. Tech. Rpt., 1965, no. 369.
H. J. Wagner and A. M. Hall: DMIC Report, 1965, no. 217.
J. M. Oblak, W. A. Owczarski, and B. H. Kear:Acta Met., 1971, vol. 19, p. 355.
K. Yagisawa and H. Fujita:Jap. J. Appl. Phys., 1967, vol. 6, p. 826.
J. P. Michal:Mem. Sei. Rev. Met., 1971, vol. 11, p. 785.
G. R. Speich:Trans. TMS-AIME, 1962, vol. 224, p. 850.
J. H. Moll, G. N. Maniar, and D. R. Muzyka:Met. Trans., 1971, vol. 2, p. 2143.
G. Faivre:Phys. Status Solidi, 1969, vol. 35, p. 249.
J. D. Eshelby:Proc. Roy. Soc, 1957, vol. A241, p. 376.
Author information
Authors and Affiliations
Additional information
This paper is based upon a thesis submitted by R. COZAR in partial fulfillment of the requirements of the degree of Doctor of Philosophy at the University of Nancy.
Rights and permissions
About this article
Cite this article
Cozar, R., Pineau, A. Morphology of y’ and y” precipitates and thermal stability of inconel 718 type alloys. Metall Trans 4, 47–59 (1973). https://doi.org/10.1007/BF02649604
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1007/BF02649604