Skip to main content
SpringerLink
Log in

Evaporation-induced evolution of the capillary force between two grains

  • Original Paper
  • Published:
Granular Matter Aims and scope Submit manuscript

Abstract

The evolution of capillary forces during evaporation and the corresponding changes in the geometrical characteristics of liquid (water) bridges between two glass spheres with constant separation are examined experimentally. For comparison, the liquid bridges were also tested for mechanical extension (at constant volume). The obtained results reveal substantial differences between the evolution of capillary force due to evaporation and the evolution due to extension of the liquid bridges. During both evaporation and extension, the change of interparticle capillary forces consists in a force decrease to zero either gradually or via rupture of the bridge. At small separations between the grains (short & wide bridges) during evaporation and at large volumes during extension, there is a slight initial increase of force. During evaporation, the capillary force decreases slowly at the beginning of the process and quickly at the end of the process; during extension, the capillary force decreases quickly at the beginning and slowly at the end of the process. Rupture during evaporation of the bridges occurs most abruptly for bridges with wider separations (tall and thin), sometimes occurring after only 25 % of the water volume was evaporated. The evolution (pinning/depinning) of two geometrical characteristics of the bridge, the diameter of the three-phase contact line and the “apparent” contact angle at the solid/liquid/gas interface, seem to control the capillary force evolution. The findings are of relevance to the mechanics of unsaturated granular media in the final phase of drying.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10

Similar content being viewed by others

References

  1. Peron, H., Delenne, J.Y., Laloui, L., El Youssoufi, M.S.: Discrete element modelling of drying shrinkage and cracking of soils. Comput. Geotech. 36, 61–69 (2009)

    Article  Google Scholar 

  2. Hu, L.B., Peron, H., Hueckel, T., Laloui, L.: Desiccation shrinkage of non-clayey soils: multi-physics mechanisms and a microstructural model. Int. J. Numer. Anal. Methods Geomech. (2012). doi:10.1002/nag.2108

  3. Hu, L.B., Peron, H., Hueckel, T., Laloui, L.: Desiccation shrinkage of non-clayey soils: a numerical study. Int. J. Numer. Anal. Methods Geomech. (2012). doi:10.1002/nag.2107

  4. Hu, L.B., Peron, H., Laloui, L., Hueckel, T.: A multi-scale multi-physics model of soil drying. ASCE Geotechnical Special Publication 211: Geo-Frontiers 2011, Advances in Geotechnical Engineering, Dallas, TX, USA, pp. 4349–4358 (2011)

  5. Hu, L.B., Peron, H., Hueckel, T., Laloui, L.: Drying shrinkage of deformable porous media: mechanisms induced by the fluid removal. In: Olson, H.W. (ed.) ASCE Geotechnical Special Publication 157: Computer Applications in Geotechnical Engineering, Geo-Denver 2007 (CD-ROM) (2007)

  6. Kowalski, S.J., Mielniczuk, B.: Analysis of effectiveness and stress development during convective and microwave drying. Dry Technol. 26, 64–77 (2008)

    Article  Google Scholar 

  7. El Youssoufi, M.S., Delenne, J.Y., Radjai, F.: Self-stresses and crack formation by particle swelling in cohesive granular media. Phys. Rev. E 71, 051307 (2005)

    Article  ADS  Google Scholar 

  8. Urso, M.E.D., Lawrence, ChJ, Adams, M.J.: A two-dimensional study of the rupture of funicular liquid bridges. Chem. Eng. Sci. 57, 677–692 (2002)

    Article  Google Scholar 

  9. Hueckel, T., Mielniczuk, B., El Youssoufi, M. S.: Micro-scale study of rupture in desiccating granular media, Proceedings of Geo-Congress 2013, Geotechnical Special Publication GSP 231, pp. 808–817, ASCE (2013)

  10. Harris, C.C., Morrow, N.R.: Pendular moisture in packings of equal spheres. Nature 203, 706–708 (1964)

    Article  ADS  Google Scholar 

  11. Gao, C.: Theory of menisci and its applications. Appl. Phys. Lett. 71, 1801–1804 (1997)

    Article  ADS  Google Scholar 

  12. Maeda, N., Israelachvili, J.N., Kohonen, M.M.: Evaporation and instabilities of microscopic capillary bridges. Proc. Natl. Acad. Sci. USA 100(3), 803–808 (2003)

    Article  ADS  Google Scholar 

  13. Cutts, R.E., Burns, S.E.: Evolution of surface area-to-volume ratio for a water meniscus evaporating between contacting silica spheres. J. Colloid Interface Sci. 343, 298–300 (2010)

    Article  Google Scholar 

  14. Zhou, Z., Li, Q., Zhao, X.S.: Evolution of interparticle capillary forces during drying of colloidal crystals. Langmuir 22, 3692–3697 (2006)

    Article  Google Scholar 

  15. Willett, ChD, Adams, M.J., Johnson, S.A., Seville, J.P.K.: Capillary bridges between two spherical bodies. Langmuir 16, 9396–9405 (2000)

    Article  Google Scholar 

  16. Rabinovich, Y.I., Esayanur, M.S., Moudgil, B.M.: Capillary forces between two spheres with a fixed volume liquid bridge: theory and experiment. Langmuir 21, 10992–10997 (2005)

    Article  Google Scholar 

  17. Butt, H.-J., Kappl, M.: Normal capillary forces. Adv. Colloid Interface Sci. 146, 48–60 (2009)

    Article  Google Scholar 

  18. Gras, J.-P., Delenne, J.-Y., El Youssoufi, M.S.: Study of capillary interaction between two grains: a new experimental device with suction control. Granul. Matter 15, 49–56 (2013)

    Article  Google Scholar 

  19. de Gennes, P.G.: Wetting: statics and dynamics. Rev. Mod. Phys. 57, 827–863 (1985)

    Article  ADS  Google Scholar 

  20. Bourgès, C., Shanahan, M.E.R.: L’influence de l’évaporation sur l’angle de contact des gouttes d’eau. C. R. Acad. Sci. Paris 316, 311–316 (1993)

    Google Scholar 

  21. Bourgès-Monnier, C., Shanahan, M.E.R.: Influence of evaporation on contact angle. Langmuir 11, 2820–2829 (1995)

    Article  Google Scholar 

  22. Marmur, A.: Soft contact: measurement and interpretation of contact angles. Soft Matter 2, 12–17 (2006)

    Article  ADS  Google Scholar 

  23. Anantharaju, N., Panchagnula, M., Net, S.: Evaporating drops on patterned surfaces: transition from pinned to moving triple line. J. Colloid Interface Sci. 337, 176–182 (2009)

    Article  Google Scholar 

  24. Bormashenko, E.: Wetting of real solid surfaces: new glance on well- known problems. Colloid Polym. Sci. 291, 339–342 (2013). doi:10.1007/s00396-012-2778-8

    Article  Google Scholar 

  25. Adamson, A.W.: Physical Chemistry of Surfaces, 3rd edn. Wiley, New York and London (1976)

    Google Scholar 

  26. Landau, L.D., Lifshitz, E.M.: Course of Theoretical Physics, Fluid Mechanics, vol. 6. Pergamon Press, Oxford (1959)

    Google Scholar 

  27. Lian, G., Thornton, C., Adams, M.J.: A theoretical study of the liquid bridge forces between two rigid spherical bodies. J. Colloid Interface Sci. 161, 138–147 (1993)

    Article  Google Scholar 

  28. Princen, H.M.: Comments on “The effect of capillary liquid on the force of adhesion between spherical solid particles”. J. Colloid Interface Sci. 26, 249–253 (1968)

    Article  Google Scholar 

  29. Erbil, H.Y.: Evaporation of pure liquid sessile and spherical suspended drops: a review. Adv. Colloid Interface Sci. 170, 67–86 (2012)

    Article  Google Scholar 

  30. Marmur, A.: Wetting on real surfaces. IS&Ts NIP 15: 1999 International Conference on Digital Printing Technologies, pp. 22–25 (1999)

  31. Bormashenko, E.: Progress in understanding wetting transitions on rough surfaces. Adv. Colloid Interface Sci. (2014) doi:10.1016/j.cis.2014.02.009

  32. Deegan, R.D., Bakajin, O., Dupont, T.F., Huber, G., Nagel, S.R., Witten, T.A.: Capillary flow as the cause of ring stains from dried liquid drops. Nature 389, 827–829 (1997)

    Article  ADS  Google Scholar 

  33. Israelachvili, J.N.: Intermolecular and Surface Forces, 3rd edn. Academic Press, USA (2011)

    Google Scholar 

  34. Bormashenko, E., Musin, E.A., Whyman, G., Zinigrad, M.: Wetting transitions and depinning of the triple line. Langmuir 28, 3460–3464 (2012)

    Article  Google Scholar 

  35. Orejon, D., Sefiane, K., Shanahan, M.E.R.: Stick-slip of evaporating droplets: substrate hydrophobicity and nanoparticle concentration. Langmuir 27, 12834–12843 (2011). doi:10.1021/la2026736

    Article  Google Scholar 

  36. Kröger, J., Rath, H.J.: Velocity and elongation rate distributions in stretched polymeric and Newtonian liquid bridges. J. Non-Newton. Fluid Mech. 57, 137–153 (1995)

    Article  Google Scholar 

  37. Mielniczuk, B., Hueckel, T., El Youssoufi, M.S.: Evolution of Laplace pressure and surface tension for evaporating two-grain water bridge. Submitted

  38. Soulié, F., Cherblanc, F., El Youssoufi, M.S., Saix, C.: Influence of liquid bridges on the mechanical behaviour of polydisperse granular materials. Int. J. Numer. Anal. Methods Geomech. 30, 213–228 (2006)

    Article  MATH  Google Scholar 

  39. Das, S.: Effect of impurities in the description of surface nanobubbles: role of nonidealities in the surface layer. Phys. Rev. E 83, 066315 (2011)

    Article  ADS  Google Scholar 

  40. Bircumshaw, L.L.: The surface tension of mixtures of alcohol and water at 25\(^{\circ }\). Chem. Soc. Trans. 121, 887 (1922)

    Article  Google Scholar 

  41. Pepin, X., Rossetti, D., Iveson, S.M., Simons, S.J.R.: Modeling the evolution and rupture of pendular liquid bridges in the presence of large wetting hysteresis. J. Colloid Interface Sci. 232, 289–297 (2000). doi:10.1006/jcis.2000.7182

    Article  Google Scholar 

  42. Willett, C.D., Adams, M.J., Johnson, S.A., Seville, J.P.K.: Effects of wetting hysteresis on pendular liquid bridges between rigid spheres. Powder Technol. 130, 63–69 (2003)

    Article  Google Scholar 

  43. Megias-Alguacil, D., Gauckler, L.J.: Capillary forces between two solid spheres linked by a concave liquid bridge : regions of existence and forces mapping. AiChE J. 55, 1103–1109 (2009)

    Article  Google Scholar 

  44. Adams, M.J., Johnson, S.A., Seville, J.P.K., Willett, C.D.: Mapping the influence of gravity on pendular liquid bridges between rigid spheres. Langmuir 18, 6180–6184 (2002)

    Article  Google Scholar 

  45. Fisher, L.R., Israelashvili, J.N.: Experimental studies on the applicability of the Kelvin equation to highly curved concave menisci. J. Colloid Interface Sci. 80, 528–541 (1981)

    Article  Google Scholar 

  46. Mielniczuk, B., El Youssoufi, M.S., Sabatier, L, Hueckel, T.: Rupture of a liquid bridge between two grains due to its evaporation. Acta Geophysica (2014). doi:10.2478/s11600-014-0225-6

  47. Young, T.: An essay on the cohesion of fluids. Philos. Trans. 65, 1071 (1805). doi:10.1098/rstl.1805.0005.JSTOR59

  48. Birch, W., Carré, A., Mittal, K.L.: Wettability techniques to monitor the cleanliness of surfaces, Chapter 13. In Kohli, R. and Mittal, K.L. (eds.) Developments in surface contamination and cleaning, William Andrew Inc (2008 )

  49. Lide, D.R. (ed.) CRC Handbook of Chemistry and Physics, 75th edition. CRC Press (1994)

  50. Decker, E.L., Frank, B., Suo, Y., Garoff, S.: Physics of contact angle measurement. Colloids Surf. A Physicochem. Eng. Asp. 156, 177–189 (1999)

    Article  Google Scholar 

  51. Wolansky, G., Marmur, A.: Apparent contact angles on rough surfaces: the Wenzel equation revisited. Colloids Surf. A Physicochem. Eng. Asp. 156, 381–388 (1999)

    Article  Google Scholar 

  52. de Gennes, P.G., Brochard-Wyart, F., Quéré, D.: Gouttes, bulles, perles et ondes. Belin, Paris (2002)

    Google Scholar 

  53. Pittoni, P.G., Chang, C.-C., Yu, T.-S., Lin, S.-Y.: Evaporation of water drops on polymer surfaces: pinning, depinning and dynamics of the triple line. Colloids Surf. A Physicochem. Eng. Asp. 432, 89–98 (2013)

    Article  Google Scholar 

  54. Wenzel, R.N.: Resistance of solid surfaces to wetting by water. Ind. Eng. Chem. 28, 988–994 (1936)

    Article  Google Scholar 

  55. Cassie, A.B.D., Baxter, S.: Wettability of porous surfaces. S. Trans. Faraday Soc. 40, 546–551 (1944)

    Article  Google Scholar 

  56. Boruvka, L., Neumann, A.W.: Generalization of the classical theory of capillarity. J. Chem. Phys. 66, 5464–5476 (1977)

    Article  ADS  Google Scholar 

  57. Gao, L., McCarthy, T.J.: How Wenzel and Cassie Were Wrong. Langmuir 23, 3762–3765 (2007)

    Article  Google Scholar 

  58. Eral, H.B.D’.t Mannetje, J.C.M., Oh, J.M.: Contact angle hysteresis: a review of fundamentals and applications. Colloid Polym. Sci. 291, 247–260 (2013)

  59. Mikami, T., Kamiya, H., Horio, M.: Numerical simulation of cohesive powder behavior in a fluidized bed. Chem. Eng. Sci. 53, 1927–1940 (1998)

    Article  Google Scholar 

  60. Soulié, F. : Cohésion par capillarité et comportement mécanique de milieux granulaires. PhD thesis, Université Montpellier 2, Montpellier (2005)

  61. Marmur, A.: Wetting on hydrophobic rough surfaces: to be heterogeneous or not to be? Langmuir 19, 8343–8348 (2003)

  62. Patankar, N.A.: Transition between superhydrophobic states on rough surfaces. Langmuir 20, 7097–7102 (2004)

    Article  Google Scholar 

  63. Rahardjo, H., Fredlund, D.G.: Experimental verification of the theory of consolidation for unsaturated soils. Can. Geotech. J. 32, 749 (1995)

  64. Peron, H., Hueckel, T., Laloui, L.: An improved volume measurement for determining soil water retention curves. Geotech. Test. J. 30, 1–8 (2007)

  65. Hueckel, T., Mielniczuk, B., El Youssoufi, M.S., Hu, L.B., Laloui, L.: A three-scale cracking criterion for drying soils. Acta Geophysica (2014). doi:10.2478/s11600-014-0214-9

Download references

Acknowledgments

The authors acknowledge the partial support of US NSF Grant #0700294 of CMMI Division, Geomechanics and Geomaterials Program (T. Hueckel) and the support of CNRS, IRSN (MIST laboratory) and the Languedoc-Roussillon region (B. Mielniczuk, M. S. El Youssoufi, T. Hueckel).

Author information

Authors and Affiliations

  1. Institut de Radioprotection et de Sûreté Nucléaire, IRSN, B.P. 3, 13115 , Saint-Paul-lez-Durance Cedex, France

    Boleslaw Mielniczuk

  2. Laboratoire de Micromécanique et d’Intégrité des Structures MIST, IRSN-CNRS-Université Montpellier 2, Montpellier, France

    Boleslaw Mielniczuk & Moulay Saïd El Youssoufi

  3. Duke University, Durham, NC, 27708, USA

    Tomasz Hueckel

  4. Laboratoire de Mécanique et Génie Civil UMR UM2-CNRS 5508, Université Montpellier 2, 34095 , Montpellier Cedex 5, France

    Moulay Saïd El Youssoufi

Authors
  1. Boleslaw Mielniczuk
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Tomasz Hueckel
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Moulay Saïd El Youssoufi
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Tomasz Hueckel.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Mielniczuk, B., Hueckel, T. & Youssoufi, M.S.E. Evaporation-induced evolution of the capillary force between two grains. Granular Matter 16, 815–828 (2014). https://doi.org/10.1007/s10035-014-0512-6

Download citation

  • Received:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10035-014-0512-6

Keywords

Search

Navigation