Skip to main content
SpringerLink
Log in

Electromigration behaviors in Sn–58Bi solder joints under different current densities and temperatures

  • Published:
Journal of Materials Science: Materials in Electronics Aims and scope Submit manuscript

Abstract

Sn–58Bi eutectic solder is attracted much attention to replace Sn–Ag–Cu Pb-free solder due to its lower melting temperature in recent years. However, its low melting temperature also raised serious electromigration (EM) reliability due to the accelerated atomic migration from the high local temperature induced by Joule heating. This paper mainly studied the EM behaviors occurred in Sn–58Bi solder joints with consideration the effect of different current densities and temperature. Variation on the atomic migration and phase coarsening were observed in Sn–58Bi solder joint, and the threshold current densities to trigger EM damage were estimated. The results showed that Bi-rich layer was produced at anode side during stressing with low current density while caused Cu cathode to dissolve into Sn–Bi solder and formed Cu6Sn5 intermetallic compounds near anode side during stressing with high current density. Accordingly, the corresponding dominant diffusing species in Sn–58Bi solder were Bi atoms at low temperature and Cu and Sn atoms at high current density, respectively. High temperature applied with EM accelerated the atomic migration. The threshold current densities at different temperature were then calculated from the thickness of Bi-rich layer at anode side. There existed a lower threshold current density at higher temperature due to the active atomic mobility. Finally, Bi phase coarsening was observed in Sn–Bi solder under different current densities and temperatures. Higher current density or higher temperature induced faster grain growth, but the applied current had a greater effect on Bi phases coarsening in Sn–Bi solder matrix than the applied temperature. The controlling kinetics on the growth of Bi phases were also suggested for the effect of current densities and temperatures.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12

Similar content being viewed by others

References

  1. S. Brandenburg, S. Yeh, Electromigration studies of flip chip bump solder joints, in Proceedings of the Surface Mount International Conference and Exhibition, San Jose, CA, 1998, pp. 337–344

  2. M.-S. Yoon, S.-B. Lee, O.-H. Kim, Y.-B. Park, Y.-C. Joo, Relationship between edge drift and atomic migration during electromigration of eutectic SnPb lines. J. Appl. Phys. 100, 033715 (2006)

    Article  Google Scholar 

  3. R. Agarwal, S.E. Ou, K.N. Tu, Electromigration and critical product in eutectic SnPb solder lines at 100 °C. J. Appl. Phys. 100, 024909 (2006)

    Article  Google Scholar 

  4. C.Y. Liu, C. Chen, K.N. Tu, Electromigration in Sn–Pb solder strips as a function of alloy composition. J. Appl. Phys. 88, 5703–5709 (2000)

    Article  CAS  Google Scholar 

  5. D. Gupta, K. Vieregge, W. Gust, Interface diffusion in eutectic Pb–Sn solder. Acta Mater. 47, 5–12 (1998)

    Article  Google Scholar 

  6. Z. Lai, D. Ye, Microstructure and fracture behavior of non eutectic Sn-Bi solder alloys. J. Mater. Sci. Mater. Electron. 27, 3182–3192 (2016)

    Article  CAS  Google Scholar 

  7. D. Ye, C. Du, M. Wu, Z. Lai, Microstructure and mechanical properties of Sn-xBi solder alloy. J. Mater. Sci. Mater. Electron. 26, 3629–3637 (2015)

    Article  CAS  Google Scholar 

  8. X. Wu, M. Xia, S. li, X. Wang, B. Liu, J. Zhang, N. Liu, Microstructure and mechanical behavior of Sn–40Bi–xCu alloy. J. Mater. Sci. Mater. Electron. 28, 15708–15717 (2017)

    Article  CAS  Google Scholar 

  9. L. Zhang, L. Sun, Y. Guo, Microstructures and properties of Sn58Bi, Sn35Bi0.3Ag, Sn35Bi1.0Ag solder and solder joints. J. Mater. Sci. Mater. Electron. 26, 7629–7634 (2015)

    Article  CAS  Google Scholar 

  10. C.-M. Chen, L.-T. Chen, Y.-S. Lin, Electromigration-induced Bi segregation in eutectic SnBi solder joint. J. Electron. Mater. 36, 168–172 (2007)

    Article  CAS  Google Scholar 

  11. C.-M. Chen, C.-C. Huang, Atomic migration in eutectic SnBi solder alloys due to current stressing. J. Mater. Res. 23, 1051–1056 (2008)

    Article  CAS  Google Scholar 

  12. X. Gu, Y.C. Chan, Electromigration in line-type Cu/Sn-Bi/Cu solder joints. J. Electron. Mater. 37, 1721–1726 (2008)

    Article  CAS  Google Scholar 

  13. X. Zhao, M. Saka, M. Muraoka, M. Yamashita, H. Hokazono, Electromigration behaviors and effects of addition elements on the formation of a Bi-rich layer in Sn58Bi-based solders. J. Electron. Mater. 43, 4179–4185 (2014)

    Article  CAS  Google Scholar 

  14. F. Wang, L. Zhou, Z. Zhang, J. Wang, X. Wang, M. Wu, Effect of Sn-Ag-Cu on the improvement of electromigration behavior in Sn-58Bi solder joint. J. Electron. Mater. 46, 6204–6213 (2017)

    Article  CAS  Google Scholar 

  15. X. Zhao, M. Muraoka, M. Saka, Length-dependent electromigration behavior of Sn58Bi solder and critical length of electromigration. J. Electron. Mater. 46, 1287–1292 (2017)

    Article  CAS  Google Scholar 

  16. T.W. Hu, Y. Li, Y.C. Chan, F.S. Wu, Effect of nano Al2O3 particles doping on electromigration and mechanical properties of Sn-58Bi solder joints. Microelectron. Reliab. 55, 1226–1233 (2015)

    Article  CAS  Google Scholar 

  17. H.W. He, G.C. Xu, F. Guo, Electromigration-induced Bi-rich whisker growth in Cu/Sn-58Bi/Cu solder joints. J. Mater. Sci. 45, 334–340 (2010)

    Article  CAS  Google Scholar 

  18. H.W. He, L.Q. Cao, L.X. Wan, H.Y. Zhao, G.C. Xu, F. Guo, Joule heating effect on oxide whisker growth induced by current stressing in Cu/Sn-58Bi/Cu solder joint. Electron. Mater. Lett. 8, 463–466 (2012)

    Article  CAS  Google Scholar 

  19. X. Gu, D. Yang, Y.C. Chan, B.Y. Wu, Effects of electromigration on the growth of intermetallic compounds in Cu/SnBi/Cu solder joints. J. Mater. Res. 23, 2591–2596 (2008)

    Article  CAS  Google Scholar 

  20. D.L. Ma, P. Wu, Effects of coupled stressing and solid-state aging on the mechanical properties of graphene nanosheets reinforced Sn-58Bi-0.7Zn solder joint. Mater. Sci. Eng. A 651, 499–506 (2016)

    Article  CAS  Google Scholar 

  21. F. Wang, L. Liu, M. Wu, D. Li, Interfacial evolution in Sn–58Bi solder joints during liquid electromigration. J. Mater. Sci. Mater. Electron. 29, 8895–8903 (2018)

    Article  CAS  Google Scholar 

  22. Y.-A. Shen, C. Chen, Effect of Sn grain orientation on formation of Cu6Sn5 intermetallic compounds during electromigration. Scripta Mater. 128, 6–9 (2017)

    Article  CAS  Google Scholar 

  23. Y. Tian, J. Han, L.M. Ma, F. Guo, The dominant effect of c-axis orientation in tin on the electromigration behaviors in tricrystal Sn-3.0Ag-0.5Cu solder joints. Microelectron. Reliab. 80, 7–13 (2018)

    Article  CAS  Google Scholar 

  24. J.R. Huang, C.M. Tsai, Y.W. Lin, C.R. Kao, Pronounced electromigration of Cu in molten Sn-based solders. J. Mater. Res. 23, 250–257 (2008)

    Article  CAS  Google Scholar 

  25. P.S. Ho, T. Kwok, Electromigration in metals. Rep. Prog. Phys. 52, 301 (1989)

    Article  CAS  Google Scholar 

  26. Z. Zhang, M. Huang, Liquid-Solid Electromigration Behavior of Cu/Sn-52In/Cu Micro-Interconnect. Acta Metall. Sin. 53, 592–600 (2017)

    CAS  Google Scholar 

  27. I.A. Blech, Electromigration in thin aluminum films on titanium nitride. J. Appl. Phys. 47, 1203–1208 (1976)

    Article  CAS  Google Scholar 

  28. M.-S. Yoon, M.-K. Ko, B.-N. Kim, B.-J. Kim, Y.-B. Park, Y.-C. Joo, Line length dependence of threshold current density and driving force in eutectic SnPb and SnAgCu solder electromigration. J. Appl. Phys. 103, 073701 (2008)

    Article  Google Scholar 

  29. Y.T. Yeh, C.K. Chou, Y.C. Hsu, C. Chen, K.N. Tu, Threshold current density of electromigration in eutectic SnPb solder. Appl. Phys. Lett. 86, 203504 (2005)

    Article  Google Scholar 

  30. I.A. Blech, C. Herring, Stress generation by electromigration. Appl. Phys. Lett. 29, 131–133 (1976)

    Article  CAS  Google Scholar 

  31. F. Guo, G. Xu, H. He, M. Zhao, J. Sun, C.H. Wang, Effect of electromigration and isothermal aging on the formation of metal whiskers and hillocks in eutectic Sn-Bi solder joints and reaction films. J. Electron. Mater. 38, 2647–2658 (2009)

    Article  CAS  Google Scholar 

  32. B.Y. Wu, M.O. Alam, Y.C. Chan, H.W. ZHONG, Joule heating enhanced phase coarsening in Sn37Pb and Sn3.5Ag0.5Cu solder joints during current stressing. J. Electron. Mater. 37, 469–476 (2008)

    Article  CAS  Google Scholar 

  33. H. Ye, C. Basaran, D.C. Hopkins, Pb phase coarsening in eutectic Pb/Sn flip chip solder joints under electric current stressing. Int. J. Solids Struct. 41, 2743–2755 (2004)

    Article  Google Scholar 

Download references

Acknowledgements

The authors would like to acknowledge the support provided by the National Natural Science Foundation of China (Grant No. 51875269) and the Postgraduate Research & Practice Innovation Program of Jiangsu Province (Grant Nos. SJCX18_0760 and KYCX17_1835).

Author information

Authors and Affiliations

  1. Provincial Key Laboratory of Advanced Welding Technology, Jiangsu University of Science and Technology, Zhenjiang, 212003, China

    Fengjiang Wang, Luting Liu, Dongyang Li & Mingfang Wu

  2. School of Materials Science & Engineering, Jiangsu University of Science and Technology, Zhenjiang, 212003, China

    Fengjiang Wang, Luting Liu, Dongyang Li & Mingfang Wu

Authors
  1. Fengjiang Wang
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Luting Liu
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Dongyang Li
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Mingfang Wu
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Fengjiang Wang.

Ethics declarations

Conflict of interest

The authors declare that they have no conflict of interests.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Wang, F., Liu, L., Li, D. et al. Electromigration behaviors in Sn–58Bi solder joints under different current densities and temperatures. J Mater Sci: Mater Electron 29, 21157–21169 (2018). https://doi.org/10.1007/s10854-018-0264-x

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10854-018-0264-x

Search

Navigation