Abstract
We study the mechanical and corrosion-mechanical properties and the behavior of hydrogen in X52 steel in the intact state and after operation for 30 yr. It is shown that the long-term operation of gas mains made of this steel is accompanied by the degradation of the metal in the bulk of the pipe wall. This is manifested, first of all, in the decrease in impact toughness, relative narrowing ψ, fracture toughness, and corrosion-cracking resistance. It is shown that the in-service embrittlement of the metal is characterized by the presence of two anomalies in its mechanical behavior, namely, its brittle fracture resistance decreases parallel with the drop of hardness and the decrease in ψ is accompanied by the increase in relative elongation. The characteristics of crack growth resistance are especially sensitive to the in-service degradation of the material. The detection of degradation is more efficient under the action of embrittling factors, such as the severe stress-strain states, low testing temperatures, and the presence of corrosive media. In general, the degradation is more pronounced for the bottom part of the operating pipes, which is explained by the negative effect of hydrogen penetrating into the metal from the transported media. A hypothesis is advanced concerning the microdamage of operating steel as the principal factor of degradation of pipes as a result of long-term operation. Note that the results of investigation of hydrogen permeability and the temperature dependences of the extraction of hydrogen from the metals in different states are in good agreement with the proposed hypothesis.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
A. Y. Krasowsky, A. A. Dolgiy, and V. M. Torop, “Charpy testing to estimate pipeline steel degradation after 30 years of operation,” in: D. Francois and A. Pineau (editors), Proc. of the Charpy Centenary Conf., Vol. 1, Poitiers (2001), pp. 489–495.
Z. V. Slobodyan, H. M. Nykyforchyn, and O. I. Petrushchak, “Corrosion resistance of pipe steel in oil-water media,” Mater. Sci., No. 3, 424–429 (2002).
Z. Slobodyan, O. Petrushchak, H. Nykyforchyn, and E. Lunarska, “Peculiarities of corrosion fracture of the inner side surface of oil pipeline,” Fiz.-Khim. Mekh. Mater., 38, Special Issue No. 3, 782–785 (2002).
H. M. Nykyforchyn, K.-J. Kurzydlowski, and E. Lunarska, “Hydrogen degradation of steels in long-term service conditions,” in: S. Shipilov (editor), Environment-Induced Cracking of Materials, Vol. 2, Prediction, Industrial Developments, and Evaluations, Elsevier, Amsterdam (2008, pp. 349–361.
G. Gabetta and M. Margarone, Corrosion and Flow Models Predictions Compared Using Case Histories, NACE Corrosion Conf. Expo Paper 07522, Nashville, USA (April 2007).
T. Hyodo, M. lino, A. Ikeda, et al., “The hydrogen degradation and hydrogen-induced cracking behavior of line pipe in dynamic full scale tests,” Corr. Sci., 27, 1077–1094 (1987).
SEP 1315. Stahl-Eisen-Prufballater des vereins Deutscher Eisengutteneute, Kerbschlagbiegeversuch mit Ermittlung von Kraft und Weg (1987).
“Standard test method for J-integral characterization of fracture toughness. ASTM E813,” in: Annual Book of ASTM Standards, Vol. 03.01, pp. 713–727.
ESIS P4-92 D, ESIS Recommendations for Stress Corrosion Testing Using Precracked Specimens (1st Draft), European Structural Integrity Society, Delft (1992).
V. M. A. Devanathan and Z. Stachurski, “The mechanism of hydrogen evolution on iron in acid solutions by determination of permeation rates,” J. Electrochem. Soc., 111, 619–623 (1964).
A. Turnbull, “Factor affecting the reliability of hydrogen permeation measurement,” Mater. Sci. Forum, 192-194, 63, (1995).
J. O. M. Bockris and P. K. Subramanyan, “Hydrogen embrittlement and hydrogen traps,” J. Electrochem. Soc., 118, 1114–1121 (1971).
E. Łunarska, “Application of hydrogen permeation technique for the estimation of gradual hydrogen-induced degradation of steel,” in: A. Zielinsi and D. Desjardins (editors), Proc. Internat. Conf. on the Environmental Degradation of Engineering Materials, 1, Gdanskie Towarzystwo Naukowe, Gdansk-Jurata (1999), pp. 32–37.
V. K. Babich, Yu. P. Gul, and I. E. Dolzhenkov, Deformation Aging of Steels [in Russian], Metallurgy, Moscow (1972).
A. G. Penkin, V. F. Terent’ev, and L. G. Maslov, Evaluation of the Degree of Degradation of the Mechanical Properties and Residual Serviceability of Pipe Steels by the Methods of Acoustic Emission and Kinetic Hardness [in Russian], www.sds.ru/articlesdegradation/index.html (2004).
H. M. Nykyforchyn, O. Z. Student, and A. D. Markov, “Abnormal behavior of the high-temperature degradation of the weld metal of low-alloy steel welded joints,” Mater. Sci., No. 1, 77–84 (2007).
K. Lublinska, O. Tsyrulnyk, M. Hredil, et al., “Stress corrosion cracking of clad structural steels after their high temperature hydrogen degradation,” Adv. Mater. Sci., 7, No. 1, 27–32 (2007).
I. M. Bernstein and G. M. Pressouyre, “The role of traps in the microstructural control of hydrogen embrittlement of steels,” in: R. A. Oriani, J. P. Hirth, and M. Smialowski (editors), Hydrogen Degradation of Ferrous Alloys, Noyes Publ., Park Ridge (1985), pp. 641–685.
H. Nykyforchyn, Z. Slobodyan, O. Petrushchak, E. Łunarska, “Rola wodoru w korozyjnym niszczenu wewnetrznych powierzchni rurociagu naftowego,” Ochrona przed Korozją, No. 45, 445–449 (2002).
A. Zagórski, W. Spychalski, H. Matysiak, et al., “Degradacja materiałów rurociajów ropy naftowej spowodowana korozją i nawodorowaniem, in: J. Lubkiewicz (editor), Pracy VII Konf. “Zarządzanie Ryzykiem w Eksploatacji Rurociągów,” Plock: Centrum Diagnostyki Rurociągów (2004), pp. 135–141 (A. Zagórski, W. Spychalski, H. Matysiak et al., “Degradation of the materials of oil pipelines caused by corrosion and hydrogenation,” in: J. Lubkiewicz (editor), Proc. VII Conf. on the Risk Maintenance in the Exploitation of Pipelines,” Płock: Pipelines Diagnostic Centre (2004), pp. 135–141.
Author information
Authors and Affiliations
Additional information
Published in Fizyko-Khimichna Mekhanika Materialiv, Vol. 44, No. 1, pp. 88–99, January–February, 2008.
Rights and permissions
About this article
Cite this article
Gabetta, G., Nykyforchyn, H.M., Lunarska, E. et al. In-service degradation of gas trunk pipeline X52 steel. Mater Sci 44, 104–119 (2008). https://doi.org/10.1007/s11003-008-9049-3
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11003-008-9049-3