Skip to main content
Erschienen in: Metallurgical and Materials Transactions A 2/2012

01.02.2012

Corrosion Study of Zinc, Nickel, and Zinc-Nickel Alloys in Alkaline Solutions by Tafel Plot and Impedance Techniques

verfasst von: Abdel-Rahman El-Sayed, Hossnia S. Mohran, Hany M. Abd El-Lateef

Erschienen in: Metallurgical and Materials Transactions A | Ausgabe 2/2012

Einloggen

Aktivieren Sie unsere intelligente Suche um passende Fachinhalte oder Patente zu finden.

search-config
loading …

Abstract

The article describes the use of Tafel plot and electrochemical impedance spectroscopy (EIS) techniques, in order to study the corrosion process of pure zinc, nickel, and synthetic Zn-Ni alloys in various concentrations (0.25 to 1 M) of KOH solution in a temperature range 298 K to 328 K (25 °C to 55 °C). The corrosion rate increases with increasing both concentration of KOH and temperature for all investigated electrodes. The results showed that the increase in Ni content improves the corrosion resistance and increases the barrier of activation energy, and the higher value of corrosion resistance is obtained at 10 pct Ni. The electrochemical measurements using two mentioned techniques are in good agreement with the results of microhardness in that the microhardness gradually increases with increasing Ni content in the alloy. Thus, the corrosion rate of these alloys is significantly reduced compared with that of pure zinc. It is observed that the Warburg tail at low frequency completely disappears at the applied potentials in the case of alloy IV (10 pct Ni) only. This indicates that the diffusion of Zn ion species is strongly reduced. Therefore, addition of Ni to Zn has a beneficial effect, because it leads to lower loss of anode material. The results obtained at certain positive potential (+420 mV vs SCE) exhibited that the semicircle diameter in the case of alloys is lower compared with that of pure zinc. This result means that the values of the charge transfer resistance (R ct ) in the case of alloys are decreased, due to the breakdown of the oxide layer at this potential. This behavior can be considered as an important criterion for a good battery anode, due to reactivation of the alloy surface at certain positive potential (+0.420 V vs SCE) and suppression of hydrogen gas compared with those of pure zinc.

Sie haben noch keine Lizenz? Dann Informieren Sie sich jetzt über unsere Produkte:

Springer Professional "Wirtschaft+Technik"

Online-Abonnement

Mit Springer Professional "Wirtschaft+Technik" erhalten Sie Zugriff auf:

  • über 102.000 Bücher
  • über 537 Zeitschriften

aus folgenden Fachgebieten:

  • Automobil + Motoren
  • Bauwesen + Immobilien
  • Business IT + Informatik
  • Elektrotechnik + Elektronik
  • Energie + Nachhaltigkeit
  • Finance + Banking
  • Management + Führung
  • Marketing + Vertrieb
  • Maschinenbau + Werkstoffe
  • Versicherung + Risiko

Jetzt Wissensvorsprung sichern!

Springer Professional "Technik"

Online-Abonnement

Mit Springer Professional "Technik" erhalten Sie Zugriff auf:

  • über 67.000 Bücher
  • über 390 Zeitschriften

aus folgenden Fachgebieten:

  • Automobil + Motoren
  • Bauwesen + Immobilien
  • Business IT + Informatik
  • Elektrotechnik + Elektronik
  • Energie + Nachhaltigkeit
  • Maschinenbau + Werkstoffe




 

Jetzt Wissensvorsprung sichern!

Fußnoten
1
JEOL is a trademark of Japan Electron Optics Ltd., Tokyo.
 
Literatur
1.
Zurück zum Zitat M. Mouanga, P. Berçot, and J.Y. Rauch: Corros. Sci., 2010, vol. 52, pp. 3984–92.CrossRef M. Mouanga, P. Berçot, and J.Y. Rauch: Corros. Sci., 2010, vol. 52, pp. 3984–92.CrossRef
2.
Zurück zum Zitat M. Mouanga, L. Ricq, J. Douglde, and P. Bercot: Corros. Sci., 2009, vol. 51, pp. 690–98.CrossRef M. Mouanga, L. Ricq, J. Douglde, and P. Bercot: Corros. Sci., 2009, vol. 51, pp. 690–98.CrossRef
3.
Zurück zum Zitat M. Mouanga and P. Bercot: Corros. Sci., 2010, vol. 52, pp. 3993–4000.CrossRef M. Mouanga and P. Bercot: Corros. Sci., 2010, vol. 52, pp. 3993–4000.CrossRef
4.
Zurück zum Zitat Y. Ein-Eli, M. Auinat, and D. Starosvetsky: J. Power Sources, 2003, vol. 114, pp. 330–37.CrossRef Y. Ein-Eli, M. Auinat, and D. Starosvetsky: J. Power Sources, 2003, vol. 114, pp. 330–37.CrossRef
5.
Zurück zum Zitat K.V. Kordesch: Batteries, Marcel Dekker, New York, NY, 1974, vol. 1, pp. 324–26. K.V. Kordesch: Batteries, Marcel Dekker, New York, NY, 1974, vol. 1, pp. 324–26.
6.
Zurück zum Zitat T.D. Dirkse and R. Timmer: J. Electrochem. Soc., 1969, vol. 116, pp. 162–65.CrossRef T.D. Dirkse and R. Timmer: J. Electrochem. Soc., 1969, vol. 116, pp. 162–65.CrossRef
7.
Zurück zum Zitat M. Meeus, Y. Strauven, and L. Groothhaert: Extended Abstracts, 15th Int. Power Sources Symp., Brighton, England, 22–25 September, 1986, pp. 281–99. M. Meeus, Y. Strauven, and L. Groothhaert: Extended Abstracts, 15th Int. Power Sources Symp., Brighton, England, 22–25 September, 1986, pp. 281–99.
8.
Zurück zum Zitat L.Z. Vorkapic, D.M. Drazic, and A.R. Despic: J. Electrochem. Soc., 1974, vol. 121, pp. 1385–85.CrossRef L.Z. Vorkapic, D.M. Drazic, and A.R. Despic: J. Electrochem. Soc., 1974, vol. 121, pp. 1385–85.CrossRef
9.
Zurück zum Zitat M. Takahashi: “Research Report for Zinc Electrode in Alkaline Solution 1985,” The Electrochemical Society of Japan, Tokyo, Japan, 1986, p. 1. M. Takahashi: “Research Report for Zinc Electrode in Alkaline Solution 1985,” The Electrochemical Society of Japan, Tokyo, Japan, 1986, p. 1.
10.
Zurück zum Zitat M. Yano, M. Nogami, I. Yonezu, K. Nishio, Y. Akai, and M. Kurimura: Denki Kagaku, 1997, vol. 65, pp. 154–58. M. Yano, M. Nogami, I. Yonezu, K. Nishio, Y. Akai, and M. Kurimura: Denki Kagaku, 1997, vol. 65, pp. 154–58.
11.
Zurück zum Zitat M. Yano, Y. Akai, M. Kurimura, S. Fujitani, and K. Nishio: Denki Kagaku, 1997, vol. 65, pp. 650–55. M. Yano, Y. Akai, M. Kurimura, S. Fujitani, and K. Nishio: Denki Kagaku, 1997, vol. 65, pp. 650–55.
12.
Zurück zum Zitat M. Yano, S. Fujitani, K. Nishio, Y. Akai, and M. Kurimura: J. Power Sources, 1998, vol. 74, pp. 129–34.CrossRef M. Yano, S. Fujitani, K. Nishio, Y. Akai, and M. Kurimura: J. Power Sources, 1998, vol. 74, pp. 129–34.CrossRef
13.
Zurück zum Zitat A. Miura, K. Takada, R. Okazaki, H. Ogawa, T. Uemura, Y. Nakamura, and N. Kasahara: Denki Kagaku, 1989, vol. 57, pp. 459–64. A. Miura, K. Takada, R. Okazaki, H. Ogawa, T. Uemura, Y. Nakamura, and N. Kasahara: Denki Kagaku, 1989, vol. 57, pp. 459–64.
14.
Zurück zum Zitat A. Miura, K. Takada, R. Okazaki, H. Ogawa, T. Uemura, Y. Nakamura, and N. Kasahara: Extended Abstracts, 55th Electrochemical Society of Japan, Tokyo, Japan, 1988, p. 16. A. Miura, K. Takada, R. Okazaki, H. Ogawa, T. Uemura, Y. Nakamura, and N. Kasahara: Extended Abstracts, 55th Electrochemical Society of Japan, Tokyo, Japan, 1988, p. 16.
15.
Zurück zum Zitat A. Miura: Extended Abstracts, 3rd Colloidal and Surface Chemistry Symp., Japanese Chemical Society, Tokyo, Japan, 1996, p. 66. A. Miura: Extended Abstracts, 3rd Colloidal and Surface Chemistry Symp., Japanese Chemical Society, Tokyo, Japan, 1996, p. 66.
16.
Zurück zum Zitat K. Yamakawa, H. Tsubakino, and K. Kawanishi: Denki Kagaku, 1991, vol. 59, p. 325. K. Yamakawa, H. Tsubakino, and K. Kawanishi: Denki Kagaku, 1991, vol. 59, p. 325.
17.
Zurück zum Zitat N. Kasahara, T. Uemura, and A. Okada: Extended Abstracts, 27th Battery Symp., The Electrochemical Society of Japan, Osaka, Japan, 1986, p. 7. N. Kasahara, T. Uemura, and A. Okada: Extended Abstracts, 27th Battery Symp., The Electrochemical Society of Japan, Osaka, Japan, 1986, p. 7.
18.
Zurück zum Zitat T. Yamasoto, T. Uemura, M. Nakamura, N. Kasahara, A. Miura, K. Takada, R. Okazaki, and H. Ogawa: Extended Abstracts, 28th Battery Symp., The Electrochemical Society of Japan, Osaka, Japan, 1987, p. 37. T. Yamasoto, T. Uemura, M. Nakamura, N. Kasahara, A. Miura, K. Takada, R. Okazaki, and H. Ogawa: Extended Abstracts, 28th Battery Symp., The Electrochemical Society of Japan, Osaka, Japan, 1987, p. 37.
19.
Zurück zum Zitat J. Dobryszycki and S. Biallozor: Corros. Sci., 2001, vol. 43, pp. 1309–19.CrossRef J. Dobryszycki and S. Biallozor: Corros. Sci., 2001, vol. 43, pp. 1309–19.CrossRef
20.
Zurück zum Zitat A. El-Sayed, H.S. Mohran, and H.M. Abd El-Lateef: J. Power Sources, 2010, vol. 195, pp. 6924–36.CrossRef A. El-Sayed, H.S. Mohran, and H.M. Abd El-Lateef: J. Power Sources, 2010, vol. 195, pp. 6924–36.CrossRef
21.
22.
23.
Zurück zum Zitat B. MacDougall and M. Cohen: J. Electrochem. Soc., 1976, vol. 123, pp. 191–97.CrossRef B. MacDougall and M. Cohen: J. Electrochem. Soc., 1976, vol. 123, pp. 191–97.CrossRef
24.
25.
26.
Zurück zum Zitat W. Paik and Z. Szklarska-Smialowska: Surf. Sci., 1980, vol. 96, pp. 401–12.CrossRef W. Paik and Z. Szklarska-Smialowska: Surf. Sci., 1980, vol. 96, pp. 401–12.CrossRef
27.
Zurück zum Zitat C.Y. Chao and Z. Szklarska-Smialowska: Surf. Sci., 1980, vol. 96, pp. 426–12.CrossRef C.Y. Chao and Z. Szklarska-Smialowska: Surf. Sci., 1980, vol. 96, pp. 426–12.CrossRef
28.
Zurück zum Zitat J.L. Ord, J.C. Clayton, and D.J. DeSmet: J. Electrochem. Soc., 1977, vol. 124, p. 1754. J.L. Ord, J.C. Clayton, and D.J. DeSmet: J. Electrochem. Soc., 1977, vol. 124, p. 1754.
29.
31.
Zurück zum Zitat A. Seghiouer, J. Chevalet, A. Barhoun, and F. Lantelme: J. Electroanal. Chem., 1998, vol. 422, pp. 113–23. A. Seghiouer, J. Chevalet, A. Barhoun, and F. Lantelme: J. Electroanal. Chem., 1998, vol. 422, pp. 113–23.
32.
Zurück zum Zitat A. El-Sayed, A.M. Shaker, and H. Gad El-Kareem: Bull. Chem. Soc. Jpn., 2003, vol. 76, pp. 1527–35.CrossRef A. El-Sayed, A.M. Shaker, and H. Gad El-Kareem: Bull. Chem. Soc. Jpn., 2003, vol. 76, pp. 1527–35.CrossRef
33.
Zurück zum Zitat S.S. Abd El Rehim, H.H. Hassan, and N.F. Mohamed: Corros. Sci., 2004, vol. 46, pp. 1071–82.CrossRef S.S. Abd El Rehim, H.H. Hassan, and N.F. Mohamed: Corros. Sci., 2004, vol. 46, pp. 1071–82.CrossRef
34.
Zurück zum Zitat B.F. Giannetti, P.T. Sumodjo, and T. Rabockai: J. Appl. Electrochem., 1990, vol. 20, pp. 672–76.CrossRef B.F. Giannetti, P.T. Sumodjo, and T. Rabockai: J. Appl. Electrochem., 1990, vol. 20, pp. 672–76.CrossRef
35.
Zurück zum Zitat H.S. Kim, K.H. Lee, and M.C. Shin: Scripta Mater., 1998, vol. 38, pp. 1549–55.CrossRef H.S. Kim, K.H. Lee, and M.C. Shin: Scripta Mater., 1998, vol. 38, pp. 1549–55.CrossRef
36.
Zurück zum Zitat A.M. Alfantazi and U. Erb: Mater. Sci. Eng., 1996, vol. A212, pp. 123–29. A.M. Alfantazi and U. Erb: Mater. Sci. Eng., 1996, vol. A212, pp. 123–29.
37.
38.
Zurück zum Zitat G. Barceló, E. García, M. Sarret, C. Müller, and J. Pregonas: J. Appl. Electrochem., 1998, vol. 28, pp. 1113–20.CrossRef G. Barceló, E. García, M. Sarret, C. Müller, and J. Pregonas: J. Appl. Electrochem., 1998, vol. 28, pp. 1113–20.CrossRef
39.
Zurück zum Zitat R. Tremont, H. De Jesus-Cardona, J. Garcia-Orozco, R.J. Castro, and C.R. Cabrera: J. Appl. Electrochem., 2000, vol. 30, pp. 737–43.CrossRef R. Tremont, H. De Jesus-Cardona, J. Garcia-Orozco, R.J. Castro, and C.R. Cabrera: J. Appl. Electrochem., 2000, vol. 30, pp. 737–43.CrossRef
40.
Zurück zum Zitat J.W. Schultze and K. Wippermann: Electrochim. Acta, 1987, vol. 32, pp. 823–31.CrossRef J.W. Schultze and K. Wippermann: Electrochim. Acta, 1987, vol. 32, pp. 823–31.CrossRef
41.
42.
Zurück zum Zitat H.J. Cleary and N.D. Greene: Corros. Sci., 1967, vol. 7, pp. 821–31.CrossRef H.J. Cleary and N.D. Greene: Corros. Sci., 1967, vol. 7, pp. 821–31.CrossRef
43.
Zurück zum Zitat I.A. Ammar and I. Kamel: Electrochim. Acta, 1971, vol. 16, pp. 1555–68.CrossRef I.A. Ammar and I. Kamel: Electrochim. Acta, 1971, vol. 16, pp. 1555–68.CrossRef
44.
Zurück zum Zitat S.A.M. Refaey, F. Taha, and T.H.A. Hasanin: Electrochim. Acta, 2006, vol. 51, pp. 2942–48.CrossRef S.A.M. Refaey, F. Taha, and T.H.A. Hasanin: Electrochim. Acta, 2006, vol. 51, pp. 2942–48.CrossRef
45.
Zurück zum Zitat D. Li, P.P. Conway, and C. Liu: Corros. Sci., 2008, vol. 50, pp. 995–1004.CrossRef D. Li, P.P. Conway, and C. Liu: Corros. Sci., 2008, vol. 50, pp. 995–1004.CrossRef
46.
Zurück zum Zitat J. Stevanovic, S. Gojkovik, A. Despic, and V. Nakic: Electrochim. Acta, 1998, vol. 43, pp. 705–11. J. Stevanovic, S. Gojkovik, A. Despic, and V. Nakic: Electrochim. Acta, 1998, vol. 43, pp. 705–11.
47.
Zurück zum Zitat A. El-Sayed, A.M. Shaker, and H.M. Abd El-Lateef: Corros. Sci., 2010, vol. 52, pp. 72–81.CrossRef A. El-Sayed, A.M. Shaker, and H.M. Abd El-Lateef: Corros. Sci., 2010, vol. 52, pp. 72–81.CrossRef
48.
Zurück zum Zitat H.S. Mohran, A. El-Sayed, and H.M. Abd El-Lateef: J. Solid State Electrochem., 2009, vol. 13, pp. 1279–90.CrossRef H.S. Mohran, A. El-Sayed, and H.M. Abd El-Lateef: J. Solid State Electrochem., 2009, vol. 13, pp. 1279–90.CrossRef
49.
Zurück zum Zitat A.J. Bard and L.R. Faulkner: Electrochemical Methods. Fundamentals and Applications, 2nd ed., Wiley, New York, NY, 2000. A.J. Bard and L.R. Faulkner: Electrochemical Methods. Fundamentals and Applications, 2nd ed., Wiley, New York, NY, 2000.
50.
Zurück zum Zitat O.E. Barcia, O.R. Mattos, N. Pebere, and B. Tribollet: J. Electrochem. Soc., 1993, vol. 140, pp. 2825–32.CrossRef O.E. Barcia, O.R. Mattos, N. Pebere, and B. Tribollet: J. Electrochem. Soc., 1993, vol. 140, pp. 2825–32.CrossRef
51.
Zurück zum Zitat C. Deslouis, B. Tribollet, G. Mengoli, and M.M. Musiani: J. Appl. Electrochem., 1988, vol. 18, pp. 374–83.CrossRef C. Deslouis, B. Tribollet, G. Mengoli, and M.M. Musiani: J. Appl. Electrochem., 1988, vol. 18, pp. 374–83.CrossRef
52.
53.
Zurück zum Zitat M. Metikos-Hukovic and S. Omanovic: J. Electroanal. Chem., 1998, vol. 455, pp. 181–89.CrossRef M. Metikos-Hukovic and S. Omanovic: J. Electroanal. Chem., 1998, vol. 455, pp. 181–89.CrossRef
54.
Zurück zum Zitat R. Nuomi, H. Nagasaki, Y. Foboh, and A. Shibuya: SAE Technical Paper Series No. 820332, presented in Detroit, MI, 1982. R. Nuomi, H. Nagasaki, Y. Foboh, and A. Shibuya: SAE Technical Paper Series No. 820332, presented in Detroit, MI, 1982.
55.
Zurück zum Zitat C. Lin and C. Huang: J. Coat. Technol. Res., 2006, vol. 3, pp. 99–104.CrossRef C. Lin and C. Huang: J. Coat. Technol. Res., 2006, vol. 3, pp. 99–104.CrossRef
56.
57.
Zurück zum Zitat J. Xu, X. Liu, X. Li, E. Barbero, and C. Dong: J. Power Sources, 2006, vol. 155, pp. 420–27.CrossRef J. Xu, X. Liu, X. Li, E. Barbero, and C. Dong: J. Power Sources, 2006, vol. 155, pp. 420–27.CrossRef
58.
Zurück zum Zitat X. Zhang: Corrosion and Electrochemistry of Zinc, Plenum Press, New York, NY, 1996. X. Zhang: Corrosion and Electrochemistry of Zinc, Plenum Press, New York, NY, 1996.
59.
Zurück zum Zitat B. Hotellaz, J.P. Bonino, and A. Rousset: J. Mater. Sci., 1999, vol. 34, pp. 881–86.CrossRef B. Hotellaz, J.P. Bonino, and A. Rousset: J. Mater. Sci., 1999, vol. 34, pp. 881–86.CrossRef
60.
Zurück zum Zitat A.W. Badawy, K.M. Ismail, and A.M. Fathi: Electrochim. Acta, 2005, vol. 50, pp. 3603–08.CrossRef A.W. Badawy, K.M. Ismail, and A.M. Fathi: Electrochim. Acta, 2005, vol. 50, pp. 3603–08.CrossRef
61.
Zurück zum Zitat M. Mokaddem, J. Tardelli, K. Ogle, E. Rocca, and P. Volovitch: Electrochem. Commun., 2011, vol. 13, pp. 42–45.CrossRef M. Mokaddem, J. Tardelli, K. Ogle, E. Rocca, and P. Volovitch: Electrochem. Commun., 2011, vol. 13, pp. 42–45.CrossRef
Metadaten
Titel
Corrosion Study of Zinc, Nickel, and Zinc-Nickel Alloys in Alkaline Solutions by Tafel Plot and Impedance Techniques
verfasst von
Abdel-Rahman El-Sayed
Hossnia S. Mohran
Hany M. Abd El-Lateef
Publikationsdatum
01.02.2012
Verlag
Springer US
Erschienen in
Metallurgical and Materials Transactions A / Ausgabe 2/2012
Print ISSN: 1073-5623
Elektronische ISSN: 1543-1940
DOI
https://doi.org/10.1007/s11661-011-0908-4

Weitere Artikel der Ausgabe 2/2012

Metallurgical and Materials Transactions A 2/2012 Zur Ausgabe

    Marktübersichten

    Die im Laufe eines Jahres in der „adhäsion“ veröffentlichten Marktübersichten helfen Anwendern verschiedenster Branchen, sich einen gezielten Überblick über Lieferantenangebote zu verschaffen.