Abstract
Pool boiling of degassed FC-72 on a plane plate heater has been studied experimentally in microgravity. A quasi-steady heating method is adopted, in which the heating voltage is controlled to increase exponentially with time. Compared with terrestrial experiments, bubble behaviors are very different, and have direct effect on heat transfer. Small, primary bubbles attached on the surface seem to be able to suppress the activation of the cavities in the neighborhoods, resulting in a slow increase of the wall temperature with the heat flux. For the high subcooling, the coalesced bubble has a smooth surface and a small size. It is difficult to cover the whole heater surface, resulting in a special region of gradual transitional boiling in which nucleate boiling and local dry area can co-exist. No turning point corresponding to the transition from nucleate boiling to film boiling can be observed. On the contrary, the surface oscillation of the coalesced bubble at low subcooling may cause more activated nucleate sites, and then the surface temperature may keep constant or even fall down with the increasing heat flux. Furthermore, an abrupt transition to film boiling can also be observed. It is shown that heat transfer coefficient and CHF increase with the subcooling or pressure in microgravity, as observed in normal gravity. But the value of CHF is quite lower in microgravity, which may be only about one third of that at the similar pressure and subcooling in terrestrial condition.
Similar content being viewed by others
References
Di Marco, P.: Review of reduced gravity boiling heat transfer: European research. J. Jpn. Microgravity Appl. 20, 252–263 (2003)
Henry, C.D., Kim, J.: A study of the effects of heater size, subcooling, and gravity level on pool boiling heat transfer. Int. J. Heat Fluid Flow 25, 262–273 (2004)
Johnson, H.A.: Transient boiling heat transfer to water. Int. J. Heat Mass Transfer 14, 67–82 (1971)
Kim, J.: Review of reduced gravity boiling heat transfer: US research. J. Jpn. Microgravity Appl. 20, 264–271 (2003)
Kim, J., Benton, J.F., Wisniewski, D.: Pool boiling heat transfer on small heaters: effect of gravity and subcooling. Int. J. Heat Mass Transfer 45, 3919–3932 (2002)
Lee, H.S., Merte, H., Chiaramonte, F.: Pool boiling curve in microgravity. J. Thermophys. Heat Transf. 11, 216–222 (1997)
Merte H., Lee H.S., Keller K.B.: Dryout and rewetting in the pool boiling experiment flown on STS-72 (PBE-IIB) and STS-77 (PBE-IIA). NASA/CR-1998-207410 (1998)
Ohta, H.: Review of reduced gravity boiling heat transfer: Japanese research. J. Jpn. Microgravity Appl. 20, 272–285 (2003)
Ohta, H., Kawasaki, K., Azuma, H., Yoda, S., Nakamura, T.: On the heat transfer mechanisms in microgravity nucleate boiling. Adv. Space Res. 24(10), 1325–1330 (1999)
Oka, T., Abe, Y., Mori, Y.H., Nagashima, A.: Pool boiling of n-pentane, CFC-113 and water under reduced gravity: parabolic flight experiments with a transparent heater. J. Heat Transfer, Trans. ASME 117, 408–417 (1995)
Rainey, K.N., You, S.M., Lee, S.: Effect of pressure, subcooling, and dissolved gas on pool boiling heat transfer from microporous surfaces in FC-72. J. Heat Transfer, Trans. ASME 125, 75–83 (2003)
Straub, J.: Boiling heat transfer and bubble dynamics in microgravity. Adv. Heat Transf. 35, 57–172 (2001)
Wan, S.X., Zhao, J.F.: Pool boiling in microgravity: recent results and perspective for the project DEPA-SJ10. Microgravity Sci. Technol. 20, 219–224 (2008)
Wei, J.J., Guo, L.J., Honda, H.: Experimental study of boiling phenomena and heat transfer performances of FC-72 over micro-pin-finned silicon chips. Heat Mass Transf. 41(8), 744–755 (2005)
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Zhao, JF., Li, J., Yan, N. et al. Bubble Behavior and Heat Transfer in Quasi-Steady Pool Boiling in Microgravity. Microgravity Sci. Technol. 21 (Suppl 1), 175–183 (2009). https://doi.org/10.1007/s12217-009-9151-7
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12217-009-9151-7