Elsevier

Journal of Catalysis

Volume 129, Issue 2, June 1991, Pages 343-355
Journal of Catalysis

Reactant-promoted reaction mechanism for water-gas shift reaction on ZnO, as the genesis of surface catalysis

https://doi.org/10.1016/0021-9517(91)90040-BGet rights and content

Abstract

The behavior of reaction intermediates in the catalytic water-gas shift reaction (WGSR) on ZnO surfaces has been studied by means of FT-IR spectroscopy, and a reactant-promoted mechanism including intermediate-reactant interaction is proposed. On-top (terminal) hydroxyl groups on Zn ions which are formed by the first-adsorbed water molecules react with CO to produce bidentate and bridge formates. Seventy percent of them were decomposed to original CO and surface hydroxyls and only 30% of them were converted to Hz and CO2 (adsorbed) under vacuum. On the contrary, 100% of the formates were converted to the WGSR products, H2, and CO, in coexistence with second-adsorbed water molecules. The rate of the formate decomposition was promoted by a factor of more than 10 by the presence of a second water molecule. The activation energy of the decomposition of the surface formates decreases in the presence of water; 155 kJ mol−1 under vacuum and 109 kJ mol−1 with ambient water. The rate-determining step of the decomposition is the scission of the C-H bond of the formates according to isotope effects. In the absence of ambient water vapor, adsorbed CO, species exist as unidentate carbonate and carboxylate on ZnO surface. At room temperature most of CO2 (ad) exist as carboxylate, and the population of unidentate carbonate increases with an increase in temperature. When the second water molecule coexists on the surface, carboxylate converts into unidentate carbonate. The surface carbonate and carboxylate were thermally stable even at 680 K by themselves, whereas they begin to desorb at room temperature in the coexistence of the adsorbed water. Steady-state rate of catalytic WGSR agree with the decomposition rates of the bidentate formate and the unidentate carbonate; the two decomposition rates are balancing during the steady-state WGSR on ZnO. Water molecules not only act as a reactant to form the formate, but also activate the bidentate formate(ad) to decompose to H2 and unidentate carbonate(ad) and promote the desorption of the carbonate as CO2.

References (21)

  • N.W. Cant et al.

    J. Catal.

    (1982)
  • T. Shido et al.

    J. Catal.

    (1990)
  • G. Hussain et al.

    Spectrochim. Acta Part A

    (1987)
  • J.M. Vohs et al.

    Surf. Sci.

    (1986)
  • M. Nishimura et al.
  • K. Yamashita et al.

    J. Catat.

    (1985)
  • K. Nakamoto

    Infrared and Raman Spectra of Inorganic and Coordination Compounds

    (1987)
  • J.J.F. Scholten et al.
  • A. Ueno et al.

    Trans. Faraday Soc.

    (1970)
  • Y. Noto et al.

    Trans. Faraday Soc.

    (1967)
There are more references available in the full text version of this article.

Cited by (123)

  • Highly sensitive electrochemical detection of Hg(II) promoted by oxygen vacancies of plasma-treated ZnO: XPS and DFT calculation analysis

    2022, Electrochimica Acta
    Citation Excerpt :

    Therefore, increasing the active sites on their surface becomes crucial for improving the sensing performance of metal oxide-based electrochemical sensors. As a type of direct broadband-gap semiconductor material with an energy gap of 3.37 eV, zinc oxide (ZnO) [6] has been utilized in many fields, such as optics [7], electronics [8], and catalysis [9]. Recently, modifications of ZnO nanomaterials have been widely reported, including noble metal loading [10,11], metallic or nonmetallic ion doping [12], compound semiconductors [13,14], surface sensitization [15], and high-energy ion implantation [16].

  • High-yield synthesis of BTEX over Na–FeAlO<inf>x</inf>/Zn–HZSM-5@SiO<inf>2</inf> by direct CO<inf>2</inf> conversion and identification of surface intermediates

    2022, Applied Catalysis B: Environmental
    Citation Excerpt :

    The DRIFTS profiles from the surface of Zn–HZSM-5(12.5)@SiO2 differed significantly from those obtained from pristine HZSM-5(12.5) (Fig. 5b, Table S9). On the surface of Zn–HZSM-5(12.5)@SiO2, the formation of CH4 and ethylene was highly suppressed, while the formation of CO2-adsorbed species (b-CO32–(Zn) [83,84], HCO3–(Al) [75,79], and HCOO–(Zn) [85,86]) was initiated. In addition, bridged CO32– species (br-CO32–) at 1704 and 1200 cm–1 [79] and gaseous CO at 2179 and 2110 cm–1, which were not observed in the DRIFTS profiles of the Na–FeAlOx and HZSM-5(12.5) catalysts, were detected on the surface of Zn–HZSM-5(12.5)@SiO2.

  • Supported and un-supported zinc and chromium oxide catalysts for lower temperature CO oxidation: A review

    2021, Environmental Challenges
    Citation Excerpt :

    During prolonged exposure, growth units of spherical molecules forms big core sphere, which provides a proper surface energy for the attachment of active molecules of ZnO. When the aging time increases, these active molecules helps in the formation of matured flower nanostructures composed of hexagonal-shaped nanorods (Shido and Iwasawa, 1991; Fujita et al., 1995). Chromium (Cr) is a hard and brittle transition metal element with the atomic number 24.

View all citing articles on Scopus
View full text