http://orcid.org/0000-0002-1829-7936
Figures
Abstract
Black soldier fly (BSF) is a generalist species able to reduce large quantities of organic substrates and is thus considered as an interesting solution for waste management. Moreover, as BSF larvae accumulate high quantities of nutrients during their growth, they are valued because of their potential to produce products such as protein meal or fat for livestock feeds. Abiotic factors can influence larva growth, and a more detailed knowledge and control of these parameters can lead to the development of mass BSF breeding for the production of innovative products for animal feeds. As little information is available on the effects of the pH of substrates and feeding systems, the aim of this study was to evaluate the impact of these two factors on the activities of BSF larvae, prepupae, and adults. An experiment was performed with two fixed factors: i) pH (4.0; 6.1; 7.5; 9.5) and ii) feeding system (batch feeding system (TFS) or daily feeding system (DFS)). The pH treatments impacted larval weight on the first, third, and fifth day, but not at the end of the trial. Larval activity increased pH values from the fourth day onward, with final values of around 8.9–9.4 in all the treatments. The weight of the prepupae ranged from between 0.094 and 0.100 g. The final weight of the larvae and pupae, sex ratio, ingested food, larval mortality, percentage of emergence, and time to reach the pupa stadium were all affected by the feeding system. DFS showed the heaviest final larval weight (0.149 g), but required a longer time (11.3 d) than TFS to reach the prepupa stadium. The findings of this research could be useful for the mass production of BSF. Evaluation of an appropriate feeding system and initial pH value of the substrate are important parameters to reduce the time and to increase the weight in the production of larvae.
Citation: Meneguz M, Gasco L, Tomberlin JK (2018) Impact of pH and feeding system on black soldier fly (Hermetia illucens, L; Diptera: Stratiomyidae) larval development. PLoS ONE 13(8): e0202591. https://doi.org/10.1371/journal.pone.0202591
Editor: Patrizia Falabella, Universita degli Studi della Basilicata, ITALY
Received: February 21, 2018; Accepted: August 5, 2018; Published: August 27, 2018
This is an open access article, free of all copyright, and may be freely reproduced, distributed, transmitted, modified, built upon, or otherwise used by anyone for any lawful purpose. The work is made available under the Creative Commons CC0 public domain dedication.
Data Availability: All relevant data are within the paper.
Funding: The authors received no specific funding for this work.
Competing interests: The authors have declared that no competing interests exist.
Introduction
The book "Limits to Growth" [1], published more than 40 years ago, emphasized the expected exponential growth of the human population would be in conflict with limited land and other resources available to support it. These issues have become a reality: the Food and Agricultural Organization of the United Nations (FAO) estimated the world population was 7.2 billion in 2014 with 2 billion being added from 1990–2014. Estimates on this continued growth indicate the human population will reach 9 billion by 2050 [2]. The daily energy intake per individual is also expected to increase from 2770 kcal presently to 3070kcal by 2050; these factors together suggest an increase in food production will be needed [3] for both food and feed uses, and, as a result, additional land will be needed to produce several key commodities (i.e. cereals, protein-containing foods). These requirements will place pressure on land and renewable water and increase environmental changes [3]. An equal redistribution of produced food will not be sufficient to close the food gap. The FAO’s “World Agriculture towards 2030/2050” report stated about 815 million people in the world were undernourished in 2016 [4], and this number will increase dramatically in the future. Therefore, new sources of food are necessary, especially as far as protein is concerned. This population growth and increased welfare will be responsible for increased meat consumption and production especially in developing countries. Forecasts show an increase of 2.7% per year of meat, which is higher than the 1.4% reported earlier [3].
The global production of feeds has reached 1.07 billion metric tons, and the trend is expected to continue to increase in developing countries [5]. As proteins are the most important component of animal feeds, new alternative sources which should not compete with land associated with soy or other crop production, are needed. Some innovative protein sources, such as algae [6], fungi [7,8], and insects have been investigated; the latter seems to be the most promising [9,10].
Insect farming is a viable solution, due to the low land and water requirements [11], and because insects can be fed pre- or post-consumer food waste [12,13]. Globally, more than 2000 insect species are consumed daily by humans, but only a few have been studied in detail to establish for their use as livestock or aquaculture feed. Some of the most studied species are the yellow mealworm (Tenebrio molitor L. (Coleoptera: Tenebrionidae)) [14], black soldier fly (BSF) (Hermetia illucens L. (Diptera: Stratiomyidae)) [15,16,17] and house fly (Musca domestica L. (Diptera: Muscidae)) [18].
BSF colonizes numerous types of decaying organic matter, including animal manure, fish offal, food waste, and vegetable waste [19,20]. This species is distributed throughout the tropics and temperate regions of the world [21]. Over the past 30 years, BSF has been studied because of its potential to reduce large quantities of organic waste. The mass production of BSF can result in several products such as protein meal [22,23,24,25,26] and fat [27,28] for feed purposes or for biodiesel production [13] as well as fertilizers [29]. As in any livestock production, abiotic factors can also influence the growth in BSF rearing, and the correct knowledge and control of these parameters can lead to the development of methods for optimizing BSF production.
The effects of substrate quality on the growth of BSF larvae have already been studied. In many cases, these studies explored the impact of broad categories of substrates on BSF development [12,15,20,30,31], survivorship [16,32,33], and conversion rates [13,30,34,35]. The role of temperature and humidity on the life-history of BSF larvae was evaluated by Holmes et al. [33], who found these two factors can impact larval development, mortality, and the emergence time of adults.
An intrinsic parameter in substrates having been examined in part is pH. Popa and Green [36] evaluated the effects of pH in a liquid medium (leachate) on larval development. Their results demonstrated larvae were able to regulate the pH to a value of almost 9.0. Allatar [37] determined BSF larvae had an impact on the pH of a liquid medium, but also indicated this impact was dependent on larval density (0.005 g/ml). Like Popa and Green [36], the author determined pH of the medium ranged between 8 and 9. So far, to the best of our knowledge, only one study has investigated the role of the initial pH on the development of BSF larvae. Ma et al. [38] investigated the effect of different initial pHs (2.0, 4.0, 6.0, 7.0, 8.0 and 10.0) on the growth performances of BSF larvae. The study pointed out how pH values of 6.0 to 10.0resulted in heavier final BSF pupal weights than lower pH values (2.0 and 4.0) and pointed out larvae regulated the final pH values from 8.0 to 8.5, except for 2.0 and 4.0, which showed a final pH value of 6.0.
Other studies have evaluated the effect of pH on other dipterans. Diets for the primary screwworm Cochliomyia hominivorax (Coquerel) (Diptera: Calliphoridae) with a pH close to 7.5 produced larger pupae than those reared on a diet with pH close to 6.8; those reared on a more acidic pH (4.0) produced the smallest pupae [39]. The growth of larval Mediterranean fruit flies, Ceratitis capitata (Wiedemann) (Diptera: Tephritidae) is optimal when reared on artificial diets with a pH of 5.0–5.5 [39, 40]. As little information is available on the effects of substrate pH and feeding systems, on the mass production of BSF, the aim of this study has been to evaluate the impact of these two factors on the larval and pupal development, as well as mortality and adult emergence of BSF.
Materials and methods
Colony
BSF eggs were collected from a colony at the Forensic Laboratory for Investigative Entomological Sciences (FLIES) Facility at Texas A&M University, College Station, TX, USA. Eggs < 24-h-old were collected using the methods described in Sheppard et al. [41] and were stored in a Rheem Environmental Chamber at 27°C, at 70% relative humidity and with a 14:10 light-dark cycle until hatching. The neonates, consisting of a batch of more or less 45 thousand larvae) were fed with a Gainesville diet (~200g, from day 0 to day 5), which is composed by 30% alfalfa, 50% wheat bran and 20% corn meal [42], with a 70% moisture content.
Experimental design
A completely randomized and fully crossed experiment was conducted considering two factors: i) 4 different pH levels (4.0; 6.1; 7.5; 9.5), and ii) 2 different feeding systems (batch feeding system (TFS) or a daily feeding system (DFS)). Four replicates were made per treatment.
BSF rearing
Five day old larvae were used in the experiments. Larvae were partitioned into allotments of 500 larvae in 8000 cm3 plastic containers (33.5 x 22.8 x 10.9 cm; H-E-B, San Antonio, TX, USA). Cups containing larvae were then placed, in a randomized design, on shelves in a climate chamber in which all the environmental conditions were controlled (29 °C and 70% RH). A data logger (Hobo U12-006, Onset Computer Corporation 470 MacArthur Blvd. Bourne, MA, USA) was used to monitor the temperature and humidity. Ten larvae per replicate were randomly selected daily and weighed using an Adventure Pro Balanec (Ohaus, Pine Brook NJ, USA; d: 0.0001) and were then returned to their respective containers. The larval rearing trials were stopped when 40% of the larvae reached the prepupal stadium in each replicate. When a replicate was stopped, remaining larvae were cleaned, and weighed and total survival recorded.
Prepupae were placed in a plastic cup (33.5 x 22.8 x 10.9 cm; H-E-B, San Antonio, TX, USA) stored in the same climate chamber under the same conditions used previously described. When the prepupae became pupae, ten individuals from each replicate were weighed individually. The percentage of emergence and sex ratio of the entire cohort were recorded. In order to evaluate the differences in weight on a DM basis, adults were sexed and oven dried (55°C, Thelco laboratory 6540, Thermo Fisher Scientific Inc., Marietta OH, USA)) until the samples stopped decreasing in weight.
Remaining residues were weighed and dried (55°C, Thelco laboratory 6540, Thermo Fisher Scientific Inc., Marietta OH, USA). The remaining residues should have only consisted of frass, but could also have contained small amounts of non -digested substrates. In order to evaluate whether the pH and feeding system affected the consumption of larvae, the amount of digested diet was calculated, in percentage, on a dry matter basis (DM) using: Ingested food = (Provided food—remaining residues/ distributed food)*100.
Substrates pH management
The Gainesville diet [42] was used as the substrate to perform the experiments, with a moisture content of 70%. Four different pH treatments were examined. Diet pH was manipulated using the following method. Citric monohydrate acid (Hearthmark, LLC dba Jarden Home Brands; Fishers, IN 46037, USA) (0.1 M) was added to the total amount of the diet, which was calculated on a daily feeding basis, as described in Tomberlin et al. [15], to decrease the pH to 4.0 ± 0.1. A sodium hydroxide (NaOH) (Sigma-Aldrich Co., Saint Louis, MO, USA) solution (0.1 M) was added to increase the pH to 7.5 ± 0.1 (low alkaline) and 9.5 ± 0.1 (high alkaline). The diet without any manipulations was used as the control (pH = 6.1 ± 0.1).
Feeding systems
The amount of food provided during the trials was calculated on the basis of the feeding rate of the Gainesville diet (40 g/daily on wet basis (WB)). The total amount of the TFS diet was calculated according to the time the local colony took to reach the prepupa stadium (480g on WB) and was distributed at the beginning of the trial, and no further amount of diet was added during the trial. An aliquot of 40g (on WB) of diet was provided daily for DFS. The exact amount of food provided in each replicate was recorded and used to calculate the Ingested food parameter.
pH evaluation
Daily, pH was measured in each replicate across treatments using by collecting 10 g substrate, placed in 50 ml glass beaker with 17 ml distilled water, and pH recorded (based on Chan and Jang [40]) using a pH meter (Hanna Instruments, H5221, Woonsocket, RI 02895; USA). Each sample was tested three times. After the measurement, the sample was reintegrated to its respective replicate. Moreover, sampling of the DFS replicates was performed before the new batch of food was provided.
Statistical analysis
The statistical analysis of the data was performed with IBM SPSS statistic v 20.0 for Windows. The normality of the data was evaluated, larval mortality (%), time and percentage of emergence of adults (%) were transformed with a square root and determined to meet parametric analysis requirements. A repeated measure ANOVA accounting for two fixed effects, “pH treatment” and “feeding system”, and a repeated measure treatment, “time” expressed in days was applied on larval weights. Interactions between the two main factors (pH and feeding system), pH and time, the feeding system and time, and the overall interaction (pH, feeding system and time) were tested. Levene’s test was used to verify the homogeneity of variance for each combination of the groups of within- and between-subject factors. Mauchly's test was used to verify the assumption of sphericity; if such an assumption was violated, the Greenhouse-Geisser or the Huynh-Feldt correction was applied (in the cases where the sphericity estimates were lower or higher than 0.75, respectively) to correct the degrees of freedom of the F-distribution. Tukey’s post hoc test was used to evaluate the differences between the pairs. The final larval and pupal weight, the adult weight of the males and females (g on DM), larval mortality (%), the percentage emergence of adults (%), the time to reach the prepupae stadium and ingested food (% on DM) were analyzed by means of two-way ANOVA. Tukey’s post hoc test was used to evaluate the differences between the pairs.
Results
Temperature and humidity recorded during the trial were 29.3 ± 1.4°C and 70.0 ± 5.0%, respectively. No treatment indicated adverse feeding and rearing conditions.
BSF growth performance
Initial larval weights (0.011 ± 0.0028 g) were not significantly different between treatments (P = 0.842). Diet pH impacted larval weight on day one, three, and five, but the larvae did not show any differences at the end of the trial (F3,24 = 1.98; P = 0.143), as shown in Fig 1. The final weight of the larvae reared on different pH diets ranged from between 0.142 and 0.153g.
Bars topped with different letters indicate a significant difference (P≤0.05) as inferred by post-hoc pairwise comparisons.
The influence of pH on the larval weight over time is presented in Fig 1. An interaction between pH and time was recorded over the experiment (P≤0.05).
The feeding system had a significant impact on the larval weight during days two to nine. The TSF treatment was ended on day 10, while a further day was needed for DFS to achieve 40% of the prepupa stadium (Fig 2). An interaction between the feeding system and time was recorded over the experiment (P≤0.05). No interaction was recorded between pH and the feeding system over the days of the trial (P = 0.455).
*: P≤0.05; **: P≤0.01; ***: P≤0.001.
The overall interaction (pH, feeding system and time) did not show a significant level (P = 0.677).
The final larval and pupal weights (g), the adult male and female weights (g on DM), sex ratio, ingested food (% DM), percent mortality of the larvae (%), percent emergence (%), and the time to emergence (d) are shown in Table 1.
Mean ±SD. DM: dry matter. Different letters within a column (life history trait) indicate significant difference for P≤0.05.
The pH did not have an impact on the final larval or pupal weight. TFS and DFS had an effect on the final larval and pupal weights (P = 0.040). The larvae grown with DFS showed a final weight of 0.149 ± 0.0008g (Table 1).
The weight of the adult males was not affected by the pH of the diet or by the feeding system, while the weight of the adult females was significantly impacted by the pH of the diet: the females deriving from pH7.5 treatments differed from all other pH. The sex ratio, ingested food (%), and larva mortality (%) were only impacted by the feeding system, with the highest values reported for DFS. The sex ratio showed a significant interaction between the two factors as reported in Table 1. Percentage emergence was impacted by pH: pH7.5 showed differences from pH4.0 and pH6.1. The percentage of emergence was significantly higher (95.6 ± 2.8%) in DFS than in TFS (85.6 ± 5.8%). The time of development to 40% prepupae was not impacted by the pH of the diet, but was significantly different between feeding systems: the larvae provided with a single lump feeding (TFS) developed the faster (9.7 ± 0.24 d).
pH evaluation
Larval activity impacted the diet pH trend during growth, and the final values were around 9.0, as detected in more detail later on. No interaction between pH and feeding system was reported. The changes in the pH of the diet over time are presented in Figs 3 and 4.
TFS: total amount of diet provided at the beginning (480g on WB).
DFS: daily allocated diet (40g/daily on WB).
Statistical analysis generally indicated differences between the pH treatments over the course of the experiment; the only days not showing any differences are the 4th and 6th days for TFS and the 4th, 8th and 10th days for DFS, as reported in Figs 3 and 4, respectively.
The results of a Post hoc comparison between the pH treatments from day 5 to end of the trial are reported in Table 2.
Different letters within a column indicate significant difference (P≤0.05).
Regardless to the feeding system, the main changes in pH in all the treatments occurred within the first four days of the trial, after which, and till the end of the trial, pH values for TFS ranged between 8.5 (pH4.0) and 9.4 (pH9.5), and ranged from between 8.8 (pH6.1) and 9.3 (pH7.5) in DFS.
The final mean pH values of the two feeding systems were 9.2 ± 0.2 (TFS) and 9.1 ± 0.2 (DFS).
Discussion
Our research demonstrated the feeding system impacted the growth performance of BSF larvae. Regardless of the feeding system, i.e. initial lump versus daily batches, BSF larvae are able to modify their feeding substrate within four day (Figs 3 and 4).
Moreover, our data demonstrate TFS resulted in the shortest development time, while DFS showed the heaviest final weight of the larvae. Moreover the differences in ingested food between TFS and DFS showed higher values in daily system compared to batch system. Considering batch system, it seems to be more efficient to gain time and to consumption of food in a mass rearing point of view. While daily system should be more efficient in a waste management treatment because larvae require more food and they consume it more than batch system.
These results could be important for realistic mass rearing productions with larger quantities of waste, if confirmed in such settings. However, a couple of parameters may be influenced differently e.g. by higher larval densities, which could result in a higher oxygen depletion and heat production than in such a pilot study as the present one [20]. Larva aeration and ventilation should also be considered in a mass rearing system, as they can be of major importance [20].
Ma et al. [38] evaluated a batch feeding system and examined the impact of the initial pH values of the substrate (pH = 2.0; pH = 4.0; pH = 6.0; pH = 7.0; pH = 8.0; pH = 10.0) on larval growth. They showed the heaviest weights were achieved for pH6.0 (0.21 g), for the control pH7.0 (0.20 g) and for pH10.0 (0.20 g), and there were no significant differences between them, while the lowest weight was found for pH2.0 (0.16g) and pH 4.0 (0.16g). Our results instead showed no differences in the final larva weight between the different pH treatments at the end of the trial. However, the feeding systems had an impact on the larval and pupal weights during the trial.
The male-to-female ratio was not influenced by the pH treatment. Sex rations were generally male-biased, a result in agreement with the results presented by Ma et al. [38] also reported a general higher number of males than females. Nevertheless, these authors reported a significant fluctuation of the ration as the pH changed, with the lowest value being recorded for the lowest pH. In contrast, we determined differences in sex ratio which potentially is a result of the interaction between pH and feeding system implemented, something not considered by Ma et al. [38].
All the final pH values of the diets after digestion ranged from 8.9 to 9.4. Similar pH values (8.9 and 9.0) were recorded in previous studies by Alattar [37] and by Popa and Green [36], respectively. Ma et al. [38] utilized the batch feeding system to evaluate modifications in the pH, and, differing from our results, they recorded a final acidic pH (6.0) of larvae reared on a diet with an initial pH of 4.0. The different results we found, compared to those of Ma et al. [38], could be ascribed to a different larva density and food distribution. In fact, in our research, the density was 60 larvae per liter, and a quantity of distributed food equal to 480 g per 500 larvae (0.96 g/larva), while in the trial by Ma et al. [38], the density was 100 larvae per liter for a food distribution of 500g for 300 larvae (≈1.6 g per larva). It is possible to hypothesize the change in pH could be correlated to the height of the provided food, which is influenced by the size of the container, by the density [37] and by the total amount of distributed food. Higher containers’ heights size have a different air circulation from that of lower ones, which could have an impact on fermentation at high temperatures (27–30°C). Unfortunately, Ma et al. [38] did not describe the size of their containers, and only the volume was mentioned. Our results have shown different kinds of feeding system could impact pH and larval growth. The larval weight differed between feeding systems from the second day of the trial onward. The TFS larvae had the heaviest weights, until the ninth day (Fig 2); however, those in the DFS treatment were the largest at the end of the experiment (Table 1, Fig 2). The cause of the heavier weights in the early days of the experiment for the TFS larvae could be ascribed to the delivery of the food altogether. This could influence the pH values [38] and the bacteria present in the diet during the trial, and the larvae could therefore have reached the optimum pH earlier than those fed under the DSF system. Moreover, the DFS larvae had to deal with a changing environment each day, which may have slowed down the feeding activity or caused a disturbance of the microflora. The TFS larvae grew faster than the DFS ones and required less time to reach the prepupa stadium than the DFs ones. Moreover, the daily delivery of the diet only had a negative impact on the growth of the DFS larvae in the early days of the experiment, as reported in Fig 2. However, the DFS larvae showed a higher final weight than the TFS larvae (Table 1). The co-digestion between larvae, bacteria and fungi may have reduced the food availability for the TFS larvae in the last days of the trial.
Our results showed BSF larvae are also capable of resisting and manipulating acidic (pH = 4.0) and basic (pH = 9.5) environments (as shown in Fig 3), thus confirming the findings of other researches with acidic pH. Alattar [37] demonstrated BSF larvae can survive in acidic environments (pH = 1.70), and Ma et al. [38] recorded a high survival, not only for an acidic diet (pH = 2, pH = 4 and pH = 6.0) but also for a neutral, pH = 7, and basic pH (pH = 8.0 and pH = 10.0). In our trial, mortality was not affected by the substrate pH, but only by the feeding system. Regardless of the pH of the substrate and of the feeding system, the here reported mortality was lower than those reported by Oonincx et al. [30] (ranging from 14 to 25%) and by Nguyen et al. [12], where mortality ranged between 19.2% and 52.8%. Conversely, our mortality results are slightly higher than the 2% of mortality reported by Tomberlin et al. [15].
Future research is needed to investigate factors impacting mortality rates. Doing so, could allow for optimal larval output.
Similar adaptations to pH have been observed in other families of Diptera. Larvae of the Yellow Fever mosquito, Aedes aegypti, L. (Diptera: Culicidae), and the black salt marsh mosquito, Aedes (Ochlerotatus) taeniorhynchus, (Wiedmann) (Diptera: Culicidae) have shown similar adaptations to low and high pH, respectively. A pH of between 4 and 11 did not negatively affect the growth of mosquito larvae or the hemolymph pH [43]. As reported by Chaudhury and Skoda [39], larvae of the blow fly, C. hominivorax, (Diptera: Calliphoridae), are able to survive on diets with pH 4.0 and pH 7.5; however, they determined larvae were smaller (51.6–53.8 mg) and had lower survivorship (47.8–59.9%) before reaching the pupal stage when reared in acidic, rather than basic diets. The larvae of the fruit fly, C. capitata Wiedemann (Diptera: Tephritidae), was found to survive over a wide pH range (3.2 to 8.0), with optimum growth occurring at a pH of 5.0–5.5 [40]. However, the mechanisms by which pH impacts the development of immature dipteran, and subsequently also their fitness, are currently not known.
pH could influence the availability of nutrients for BSF larvae by affecting performance of enzymes present in the gut of the larvae [44]. The enzymes of the salivary gland and of the gut of BSF larvae seem to play an important role in the ability of this species to digest different kinds of decaying organic matter [44]. The main discovered enzymes of the digestive apparatus are amylases, lipases and proteases. This enzymatic variability makes BSF a polyphagous species. The protease activity is in particular related to the pH, and the activity increases at a pH of 8.0, compared to lower acidic pH values. BSF larvae could operate a change in the substrate toward a basic pH value [44]. In our study, the BSF larvae alkalized the substrate up to 9.4. This could have promoted protease activity, which enhanced the protein availability, thus positively influencing invertebrate growth [45].
The abiotic conditions, such as pH, have an impact on the microbial communities within a given environment. Shifts in pH could also have an impact on other species, comprising the detritivorous community, and thus BSF. As reported by Lam et al. [46], house fly adults respond to the bacteria present in chicken manure. Similarly, house flies are highly selective regarding oviposition sites, especially if conspecific eggs are present. Lam et al. [47] determined bacteria proliferating on eggs changed over time. They determined if conspecific eggs were deposited prior to bacteria reaching a 106–107 CFU threshold in the oviposition substrate, the likelihood of survival increased significantly (more than 40% of larvae survived).
If the eggs were deposited after this threshold was reached, the larvae resulting from the already present eggs would cannibalize the deposited secondary eggs. These roles played by bacteria could be partially governed by the pH, which is known to partially regulate cell physiology, such as the anion and cation flows across cell membranes [48]. Similarly, the larvae of the fruit fly, Dacus tryoni, (Froggatt) (Diptera: Tephritidae), were not able to survive in the absence of certain bacteria, which were determined to be a part of their dietary needs [49]. This relationship between bacteria and larval fly development appears to be highly selective. Chandler et al. [50] demonstrated external and internal bacteria communities, associated with 14 species of Drosophila (Diptera: Drosophilidae), were highly restricted with four families, which represented 85% of the diversity.
Apart from regulating the oviposition site selection of the BSF [51], bacteria (e.g., Bacillus subtilis) have been used as a probiotic to enhance the larval development of this species [52]. In fact, the larval (0.0848–0.0946 g) and prepupal weight (0699–0.0766 g), as well as the adult body length (1.22–1.25 cm) increased, compared to specimens reared on a control diet (0.0775 g; 0.0606 g; 1.20–1.18cm; larvae, prepupae and adults, respectively) [52]. Thus, BSF larvae might modify the environment to a specific pH (8.5–9.2) in order to promote the growth of bacteria resulting in enhanced development and survivorship. Jeon et al. [53] showed the composition of bacteria communities in the gut of BSF larvae by pyrosequencing of the extracted intestinal metagenomic DNA, and they determined the composition was completely different from other species.
pH could also play a significant role on the growth and proliferation of pathogens, and could represent a food safety strategy [54]. Escherichia coli is sensitive to acidic environments [55] and values below 2.5 strongly inhibit its growth [56]. Furthermore, as reported by Mendonca et al. [57], high pH values (12.0) negatively affected Gram-negative bacteria (E. coli 0157:H7, Salmonella enteritidis ATCC 13706, and Listeria monocytogenes F5069), and destroy the microbial cell membranes.
In addition, BSF has shown the ability to reduce the populations of S. enterica and E. coli in chicken manure, by increasing the pH to 8.8–9.2. As previously reported by Erickson et al. [58], this could have been the result of the waxing level of ammonia, which is physiologically produced by the larval metabolism. The impact of ammonia on bacteria was also previously observed by Turnbull and Snoeyenbos [59]: increasing levels of ammonia in poultry manure progressively reduced the S. enterica population over a period of 11 days until it disappeared.
BFS is a polyphagous species that is able to grow under different substrate conditions. Our results demonstrated BSF larvae are able to survive over a wide range of pH, and larvae shift the pH to a more preferred pH condition, which, in this trial, seems to be around pH9. These findings confirm the results of previous studies and they help improve our understanding of this relationship and could be used to optimize the mass production of BSF under industrialized conditions. Special care should be taken to determine the pH of substrates provided to larvae in order to maximize the larval weight and production. Nevertheless, not only was the pH found to influence the development time, both of which were also influenced to a great extent by the feeding system. Even though no interaction was found in this research between these two main factors (pH and feeding system), further research is still needed concerning the relationship between pH and the associated microbial community within a substrate, as these factors most likely covary with and play an important role in regulating the growth and survival of BSF larvae.
Acknowledgments
Thanks are due to the F.L.I.E.S. Facility members who helped us to perform the experiment at the Texas A&M University, College Station, TX US. Thanks to Dr. Jonathan A. Cammack for early review. Thanks are due to Prof. Dario Sacco, Department of Agricultural, Forest and Food Sciences, University of Torino, Grugliasco, Italy and Dr. Paolo Tizzani World Organisation for Animal Health (OIE), Paris France who helped for statistical analysis.
References
- 1.
Meadows DH, Meadows DL, Randers J, Behrens WW. The limits to growth. New York, 102, 27; 1972.
- 2.
FAOSTAT. “Statistical Pocketbook, World food and agriculture". 2015: 236. http://www.fao.org/3/a-i4691e.pdf
- 3.
Alexandratos N, Bruinsma J. World agriculture towards 2030/2050: the 2012 revision. ESA Working paper. 2012;12: 03 http://www.fao.org/fileadmin/templates/esa/Global_persepctives/world_ag_2030_50_2012_rev.pdf
- 4.
FAO. The State of Food Security and Nutrition in the World 2017. Building resilience for peace and food security. Rome, FAO. 2017: 1–132. http://www.fao.org/3/a-I7695e.pdf
- 5.
Alltech. 7 insights from Alltech’s 7th Annual Global Feed Survey. 05 January 2018. https://go.alltech.com/alltech-feed-survey?utm_campaign=2018%20Global%20Feed%20Survey&utm_medium=email&_hsenc=p2ANqtz-91HGvoDc3AMw-c2cnJXayUZRhiFSwK1CTXHFw_PhnMHIQZKIWp_SO4D_GdRT0JB3l0E89TZnCJJJeuQuNf4FQ280YHGw&_hsmi=60242964&utm_content=60242964&utm_source=hs_email&hsCtaTracking=e3145daf-3bca-43fd-89ed-5fba27b8a497%7C3b56cf5e-9c3a-4878-82c2-7fde3862fd25
- 6. Holman BWB, Malau-Aduli AEO. Spirulina as a livestock supplement and animal feed. J Anim Physiol Anim Nutr. 2013;97(4): 615–623. pmid:22860698
- 7. Villas-Bôas SG, Esposito E, Mitchell DA. Microbial conversion of lignocellulosic residues for production of animal feeds. Anim Feed Sci Technol. 2002;98(1): 1–12.
- 8. Nitayavardhana S, Khanal SK. Innovative biorefinery concept for sugar-based ethanol industries: production of protein-rich fungal biomass on vinasse as an aquaculture feed ingredient. Bioresour Technol. 2010;101(23): 9078–9085. pmid:20688513
- 9. Henry M, Gasco L, Piccolo G, Fountoulaki E. Review on the use of insects in the diet of farmed fish: past and future. Anim Feed Sci Technol. 2015;203: 1–22.
- 10.
Gasco L, Gai F, Maricchiolo G, Genovese L, Ragonese S, Bottari T, et al. Fish Meal Alternative Protein Sources For Aquaculture Feeds. In: Parisi S. editor: SpringerBriefs in Molecular Science. Chemistry of Foods: Feeds for the Aquaculture Sector—Current Situation and Alternative Sources, 2018 in press Forthcoming.
- 11.
van Huis AJ, Van Itterbeeck H, Klunder E, Mertens A, Halloran G, Muir P, et al. Edible insects: future prospects for food and feed security, FAO, Forestry Paper; 2013.
- 12. Nguyen TTX, Tomberlin JK, Vanlaerhoven S. Influence of resources on Hermetia illucens (Diptera: Stratiomyidae) larval development. J Med Entomol. 2013;50(4): 898–906. pmid:23926790
- 13. Leong SY, Kutty SRM, Malakahmad A, Tan CK. Feasibility study of biodiesel production using lipids of Hermetia illucens larva fed with organic waste. Waste Manag. 2016;47: 84–90. pmid:25872864
- 14. van Broekhoven S, Oonincx DG, van Huis A, van Loon JJ. Growth performance and feed conversion efficiency of three edible mealworm species (Coleoptera: Tenebrionidae) on diets composed of organic by-products. J Insect Physiol. 2015;73: 1–10. pmid:25576652
- 15. Tomberlin JK, Sheppard DC, Joyce JA. Selected Life-History Traits of Black Soldier Flies (Diptera: Stratiomyidae) Reared on Three Artificial Diets. Ann Entomol Soc Am. 2002;95(3): 379–386.
- 16. Tschirner M, Simon A. Influence of different growing substrates and processing on the nutrient composition of black soldier fly larvae destined for animal feed. J Insects Food Feed. 2015;1(4): 249–259.
- 17. Cammack JA, Tomberlin JK. The Impact of Diet Protein and Carbohydrate on Select Life-History Traits of The Black Soldier Fly Hermetia illucens (L.)(Diptera: Stratiomyidae). Insects, 2017;8(2): 56. pmid:28561763
- 18. Zhu FX, Wang WP, Hong CL, Feng MG, Xue ZY, Chen XY, Yao YL, et al. Rapid production of maggots as feed supplement and organic fertilizer by the two-stage composting of pig manure. Bioresour Technol. 2012;116: 485–491. pmid:22541952
- 19. Nguyen TTX, Tomberlin JK, Vanlaerhoven S. Ability of Black Soldier Fly (Diptera: Stratiomyidae) Larvae to Recycle Food Waste. Environ Entomol. 2015;44(2): 406–410. pmid:26313195
- 20. Meneguz M, Schiavone A, Gai F, Dama A, Lussiana C, Renna M, et al. Effect of rearing substrate on growth performance, waste reduction efficiency and chemical composition of black soldier fly (Hermetia illucens) larvae. J Sci Food Agric. ‘‘Forthcoming”. pmid:29752718
- 21. Leclerq M. Dispersion et transport des insectes nuisibles: Herrnetia illucens L. (Diptera Stratiomyidae). Bull Rech Agron Gembloux N.S. 1969;4: 139–43.
- 22. Roncarati A, Gasco L, Parisi G, Terova G. Growth performance of common catfish (Ameiurus melas Raf.) fingerlings fed Tenebrio molitor meal diet. J Insects Food Feed: 2015;1(3): 233–240.
- 23. Gasco L, Henry M, Piccolo G, Marono S, Gai F, Renna M, et al. Tenebrio molitor meal in diets for European sea bass (Dicentrarchus labrax L.) juveniles: growth performance, whole body composition and in vivo apparent digestibility. Anim Feed Sci Technol. 2016;220: 34–45.
- 24. Marono S, Loponte R, Lombardi P, Vassalotti G, Pero M, Russo F, et al. Productive performance and blood profiles of laying hens fed Hermetia illucens larvae meal as total replacement of soybean meal from 24 to 45 week of age. Poult Sci. 2017;96:1783–1790. pmid:28339710
- 25. Renna M., Schiavone A., Gai F., Dabbou S., Lussiana C., Malfatto , et al. Evaluation of the suitability of a partially defatted black soldier fly (Hermetia illucens L.) larvae meal as ingredient for rainbow trout (Oncorhynchus mykiss Walbaum) diets. J Anim Sci Biotechnol. 2017;8(1): 57. pmid:28680591
- 26. Schiavone A, De Marco M, Martínez S, Dabbou S, Renna M, Madrid J, et al. Nutritional value of a partially defatted and a highly defatted black soldier fly larvae (Hermetia illucens L.) meal for broiler chickens: apparent nutrient digestibility, apparent metabolizable energy and apparent ileal amino acid digestibility. J Anim Sci Biotechnol. 2017a;8(1): 51. pmid:28603614
- 27. Schiavone A, Cullere M, De Marco M, Meneguz M, Biasato I, Bergagna S, et al. Partial or total replacement of soybean oil by black soldier larvae (Hermetia illucens L.) fat in broiler diets: effect on growth performances, feed-choice, blood traits, carcass characteristics and meat quality. Ital J Anim Sci. 2017b;16:93–100.
- 28. Schiavone A, Dabbou S, De Marco M, Cullere M, Biasato I, Biasibetti E, et al. Black soldier fly (Hermetia illucens L.) larva fat inclusion in finisher broiler chicken diet as an alternative fat source. Animal. 2018 pmid:29343316
- 29. Choi Y, Choi J, Kim J, Kim M, Kim W, Park K, et al. Potential Usage of Food Waste as a Natural Fertilizer after Digestion by Hermetia illucens (Diptera: Stratiomyidae). Int J Indust Entomol. 2009;19(1): 171–174.
- 30. Oonincx DGAB, van Broekhoven S, van Huis A, van Loon JJA. Feed conversion, survival and development, and composition of four insect species on diets composed of food by-products. PLoS ONE. 2015;10(12): 1–20. pmid:26699129
- 31. Tinder AC, Puckett RT, Turner ND, Cammack JA, Tomberlin JK. Bioconversion of sorghum and cowpea by black soldier fly (Hermetia illucens (L.)) larvae for alternative protein production. J Insects Food Feed, 2017;3(2): 121–130.
- 32. Tomberlin JK, Adler PH, Myers HM. Development of the black soldier fly (Diptera: Stratiomyidae) in relation to temperature. Environ Entomol. 2009;38(3): 930–934. pmid:19508804
- 33. Holmes ALA, Vanlaerhoven SL, Tomberlin JK, Holmes LA. Relative Humidity Effects on the Life History of Hermetia illucens (Diptera : Stratiomyidae) Relative Humidity Effects on the Life History of Hermetia illucens (Diptera: Stratiomyidae). Environ Entomol. 2012;41(4): 971–978.
- 34. Diener S, Solano NMS, Gutiérrez FR, Zurbrügg C, Tockner K. Biological treatment of municipal organic waste using black soldier fly larvae. Waste and Biomass Valorization, 2011;2(4): 357–363.
- 35. Parra Paz AS, Soraya C, Gómez R. Effects of larval density and feeding rates on the bioconversion of vegetable waste using black soldier fly larvae Hermetia illucens (L.),(Diptera: Stratiomyidae). Waste and Biomass Valorization. 2015;6(6): 1059–1065.
- 36. Popa R, Green TR. Using black soldier fly larvae for processing organic leachates. J Econ Entomol. 2012;105(2): 374–378. pmid:22606806
- 37.
Alattar AM. Biological treatment of leachates of microaerobic fermentation. M.Sc. Thesis, Portland State University. 2012. https://pdxscholar.library.pdx.edu/cgi/viewcontent.cgi?article=1904&context=open_access_etds
- 38. Ma J, Lei Y, Yu Z, Zhang J, Li W, Li Q, et al. Dynamic Effects of Initial pH of Substrate on Biological Growth and Metamorphosis of Black Soldier Fly (Diptera: Stratiomyidae). Environ Entomol. 2018. “Forthcoming”. pmid:29325020
- 39. Chaudhury MF, Skoda SR. Diet pH, and Viscosity Affect Development and Survival of Screwworm Larvae (Diptera: Calliphoridae). J Econ Entomol. 2009;102(2): 799–803. pmid:19449663
- 40. Chan HT Jr, Jang EB. Diet pH effects on mass rearing of Mediterranean fruit fly (Diptera: Tephritidae). J Econ Entomol. 1995;88(3): 569–573.
- 41. Sheppard DC, Tomberlin JK, Joyce JA, Kiser BC, Sumner SM. Rearing methods for the black soldier fly (Diptera: Stratiomyidae). J Med Entomol. 2002;39(4): 695–698. pmid:12144307
- 42. Hogsette JA. New diets for production of house flies and stable flies (Diptera: Muscidae) in the laboratory. J Econ Entomol. 1992;85(6): 2291–2294. pmid:1464690
- 43. Clark TM, Flis BJ, Remold SK. pH tolerances and regulatory abilities of freshwater and euryhaline Aedine mosquito larvae. J Exp Biol. 2004;207(13): 2297–2304.
- 44. Kim W, Bae S., Park K., Lee S, Choi Y, Han S, et al. Biochemical characterization of digestive enzymes in the black soldier fly, Hermetia illucens (Diptera: Stratiomyidae). J Asia Pac Entomol. 2011;14(1): 11–14.
- 45. Wissinger SA, Eldermire C, Whissel JC. The role of larval cases in reducing aggression and cannibalism among caddisflies in temporary wetlands. Wetlands. 2004;24(4): 777–783.
- 46. Lam K, Thu K, Tsang M, Moore M, Gries G. Bacteria on housefly eggs, Musca domestica, suppress fungal growth in chicken manure through nutrient depletion or antifungal metabolites. Naturwissenschaften. 2009a;96(9): 1127–1132. pmid:19636523
- 47. Lam K, Geisreiter C, Gries G. Ovipositing female house flies provision offspring larvae with bacterial food. Entomol Exp Appl. 2009b;133(3): 292–295.
- 48.
Booth IR. The regulation of intracellular pH in bacteria. In Novartis Foundation Symposium 221-Bacterial Responses to Ph John Wiley & Sons, Ltd. 2007. 19–37. 10.1002/9780470515631.ch3.
- 49. Drew RAI, Courtice AC, Teakle DS, Bacteria as a natural source of food for adult fruit flies (Diptera: Tephritidae). Oecologia. 1983;60(3): 279–284. pmid:28310683
- 50. Chandler JA, Lang JM, Bhatnagar S, Eisen JA, Kopp A. Bacterial communities of diverse Drosophila species: ecological context of a host–microbe model system. PLoS Genetics. 2011;7(9): pmid:21966276
- 51. Zheng L, Crippen TL, Holmes L, Singh B, Pimsler ML, Benbow ME, et al. Bacteria mediate oviposition by the black soldier fly, Hermetia illucens (L.),(Diptera: Stratiomyidae). Sci Rep. 2013;3: 2563. pmid:23995019
- 52. Yu G, Cheng P, Chen Y, Li Y, Yang Z, Chen Y, et al. Inoculating poultry manure with companion bacteria influences growth and development of black soldier fly (Diptera: Stratiomyidae) larvae. Environ Entomol. 2011;40(1): 30–35. pmid:22182608
- 53. Jeon H, Park S, Choi J, Jeong G, Lee SB, Choi Y, et al. The intestinal bacterial community in the food waste-reducing larvae of Hermetia illucens. Curr Microbiol. 2011; 62(5): 1390–1399. pmid:21267722
- 54. Alpas H, Kalchayanand N, Bozoglu F, Ray B. Interactions of high hydrostatic pressure, pressurization temperature and pH on death and injury of pressure-resistant and pressure-sensitive strains of foodborne pathogens. Int J Food Microbiol. 2000;60(1): 33–42. pmid:11014520
- 55. Graeme WN, Sven L, Christa S, Prosser JI. The influence of soil pH on the diversity, abundance and transcriptional activity of ammonia oxidizing archaea and bacteria. Environ Microbiol. 2008;10(11): 2966–2978 pmid:18707610
- 56. Benjamin MM, Datta AR. Acid tolerance of enterohemorrhagic Escherichia coli. Appl Environ Microbiol. 1995;61(4): 1669–1672. 0099-2240/95/$04.0010. pmid:7747983
- 57. Mendonca AF, Amoroso TL, Knabel SJ. Destruction of gram-negative food-borne pathogens by high pH involves disruption of the cytoplasmic membrane. Appl Environ Microbiol. 1994;60(11): 4009–4014. 0099-2240/94/$04. pmid:7993089
- 58. Erickson MC, Islam M, Sheppard C, Liao J, Doyle MP. Reduction of Escherichia coli O157: H7 and Salmonella enterica serovar enteritidis in chicken manure by larvae of the black soldier fly. J Food Prot. 2004; 67(4): 685–690. pmid:15083719
- 59. Turnbull PCB, Snoeyenbos GH. The roles of ammonia, water activity, and pH in the salmonellacidal effect of long-used poultry litter. Avian diseases 1973;17(1): 72–86. pmid:4572573