Next Article in Journal
Mass Transfer Features of Wavy-Bottomed Cascade Photobioreactors
Next Article in Special Issue
Raman Calibration Models for Chemical Species Determination in CO2-Loaded Aqueous MEA Solutions Using PLS and ANN Techniques
Previous Article in Journal
Synthesis and Structural Characterisation of Yttrium-Doped α-Zirconium Phosphate
Previous Article in Special Issue
Life Cycle Assessment of Solid Recovered Fuel Gasification in the State of Qatar
 
 
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Article

Features of the Chemical Interaction of 2-Furaldehyde and 1,3,5-Trihydroxybenzene in an Alkaline Medium to Obtain a Plasticizing Additive

by
Valentina Anatolyevna Poluektova
,
Natalia Igorevna Cherkashina
*,
Sergey Aleksandrovich Starchenko
and
Dmitriy Sergeevich Romanyuk
Department of Theoretical and Applied Chemistry, Belgorod State Technological University Named after V.G. Shukhov, 308012 Belgorod, Russia
*
Author to whom correspondence should be addressed.
ChemEngineering 2021, 5(4), 84; https://doi.org/10.3390/chemengineering5040084
Submission received: 29 October 2021 / Revised: 24 November 2021 / Accepted: 3 December 2021 / Published: 8 December 2021
(This article belongs to the Special Issue Feature Papers in Chemical Engineering)

Abstract

:
The paper presents data on the study of the polycondensation of 2-furaldehyde and 1,3,5-trihydroxybenzene in an alkaline medium to obtain a plasticizing additive. Results are presented on the study of the products of the separate interaction of 1,3,5-trioxybenzene and 2-furaldehyde with NaOH, and the joint polycondensation of 1,3,5-trioxybenzene with 2-furaldehyde with NaOH by UV spectroscopy. The structure of the product of the interaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium was studied by IR spectroscopy. Stronger C–H bonds appear in the IR spectrum and stretching vibrations of the C = O group are not observed, which confirms the production of a new compound. The optimal dosage of the developed plasticizing additive has been established as 0.3% of the cement mass (calculated on dry matter). The developed plasticizing additive can significantly reduce the water-cement ratio while maintaining the strength characteristics of cement compositions. In addition, when using the additive, the strength characteristics are significantly increased with a reduced water-cement ratio.

1. Introduction

The use of chemical additives in building materials science makes it possible to improve the physical and mechanical characteristics of materials, and to simplify the technological process of their production [1,2,3]. Particular attention has been paid to additives for cement products [4,5,6]. The introduction of plasticizing additives allows you to regulate the rheological properties of the cement mixture, reduce the water-cement ratio, and ultimately leads to an increase in the mechanical properties of the concrete, or a decrease in its cost, by reducing the amount of cement in the composite formulations without reducing the physical and mechanical properties of the finished products [7,8,9].
The improvement of the technology for obtaining new self-compacting concrete (SCC) with improved rheotechnological and increased strength characteristics is continuously associated with the development of new plasticizing and superplasticizing additives. At the moment, there are a huge number of different superplasticizers available for cement systems [10,11,12].
Wu et al. [13] showed a positive effect of the use of a superplasticizer based on naphthalene and polycarboxylic acid. In their study, Wu et al. introduced a naphthalene-based superplasticizer in an amount of 0.8 to 2.0 wt.% and a superplasticizer based on polycarboxylic acid, also in an amount of 0.8 to 2.0 wt.%, in sulfoaluminate cement. A significant increase in the start and end of the setting of the cement was found.
Coppola et al. [14] developed a new phosphonate-based superplasticizer using an amino-methane-phosphonic polymer. The developed superplasticizer showed better characteristics in terms of reducing the water-cement ratio and maintaining workability compared to additives based on naphthalenesulfonate.
Plasticizers can be classified according to the mechanism of action on cement systems. The earliest plasticizers acted on cement systems through the effect of electrostatic repulsion of the cement particles. These were superplasticizers based on naphthalene-formaldehyde polycondensates [15], based on melamine-formaldehyde condensates [16], and based on lignosulfonates [17]. Such plasticizers have a minimal plasticizing effect. The new generation plasticizers work according to a completely different principle and, in terms of efficiency, they can already be classified as hyperplasticizers. Hyperplasticizers are produced based on polyacrylates [18,19] and polycarboxylates [20,21]. Their mechanism of action on cement slurries is due to the predominant steric effect [22]. Much research has been devoted to the creation of superplasticizers and hyperplasticizers based on polycarboxylates [23,24,25].
Zhu et al. [26] established the possibility of synthesizing a modifier based on carboxylate and citric acid. Akhlaghi et al. [27] established the possibility of synthesizing a superplasticizer based on polycarboxylate and acrylic acid. They selected two co-monomers (i) 2-acrylamido-2-methylpropane sulfonic acid (AMPS) and (ii) vinylphosphonic acid (VPA) to be incorporated into the acrylic acid (AA) backbone of the PCEs. By adding 0.4% of the optimized superplasticizer, a 90% increase in flow was achieved.
Another promising direction is the creation of a superplasticizer based on furfural (2-furancarbaldehyde). Furfural is a heterocyclic aldehyde of the furan series (2-furaldehyde). Furfural is obtained by acid-catalytic conversion of pentose carbohydrates, in particular, agricultural waste of herbaceous plants [28,29,30]. Due to this, furfural-based superplasticizers will have a much lower cost compared to traditional superplasticizers.
This work presents data on the synthesis of a plasticizing additive based on 2-furaldehyde and 1,3,5-trihydroxybenzene, including the study of the chemistry of the reaction between the components, as well as data on the effect of the plasticizing additive on cement compositions.

2. Materials and Methods

2.1. Materials

The following components were used as reagents for the synthesis of a plasticizing additive (20% aqueous solution of 1,3,5-trihydroxybenzene-2-furaldehyde oligomer):
-
phloroglucinol (1,3,5-trioxybenzene); manufactured by Panreac AppliChem. Density 1.46 g/cm3.
-
furfural (2-furaldehyde); manufacturer by Sigma-Aldrich (Saint Louis, MO, USA). Density 1.16 g/cm3; the content of the basic substance is not less than 99.3%.
-
sodium hydroxide (NaOH); the content of the main substance is not less than 98%. Manufactured by Panreac AppliChem.
The chemical formulae of the substances used to synthesize the superplasticizer are shown in Figure 1.
Determination of the plasticizing ability of the additive was based on Portland cement grade CEM I 42.5. The specific surface area of the Portland cement was 250 ± 10 m2/kg.
The synthesis of the superplasticizer proceeded as follows: 2 cm3 of a 30% NaOH solution was introduced into a round-bottom flask with a portion of 1,3,5-trihydroxybenzene weighing 1.22 g, after which 9.4 cm3 of distilled water was poured into the mixture while stirring. The mixture was heated in a thermostat to a temperature of 70 °C using a water heat carrier. This temperature is necessary for the reaction to proceed according to the data of previous studies [31].
To assess the effect of the rate of addition of the condensing agent (2-furaldehyde), two flasks with the same composition were prepared. After the temperature of the mixture reached 70 °C, 1 g of 2-furaldehyde was immediately introduced into the first flask, and the same mass of 2-furaldehyde was introduced into the second flask but only at a rate of 0.05 mL/min. Both mixtures were thermostatically controlled while stirring at a speed of 300 rpm for 90 min. After this time, the flasks with condensation products were cooled to room temperature.

2.2. Research Methods

The chemical structure of the starting monomers was investigated by spectroscopy using a Specord 200 plus spectrophotometer (manufactured by Analytik Jena AG, Jena, Germany). The UV spectra of the synthesis products were also used to study the chemical structure of the oligomers obtained (under various conditions). For refraction of radiation into the spectrum, a monochromator with a concave silver holographic grating was used, deuterium and halogen lamps were used as radiation sources, and an ultra-precise photodiode was used as an analyzer. For spectrometric studies, the solutions were prepared as follows: 0.1 cm3 of the synthesized compound was placed in a volumetric flask with a capacity of 250 cm3, dissolved in distilled water, and the volume of the solution was brought up to the mark. Then 20 cm3 of the finished solution was transferred into a volumetric flask with a capacity of 100 cm3, dissolved in purified water, and the volume of the solution was brought up to the mark. The UV spectra of the prepared solutions were recorded in the range from 200 to 700 nm; distilled water was used as a reference solution. To record the UV spectra of the starting monomers, we used their aqueous solutions prepared as follows: 10 cm3 of distilled water was added to a sample weighing 2 g.
The acquisition of IR spectra was carried out on a VERTEX 70 Fourier-IR spectrometer (manufactured by Bruker Optik GmbH, Ettlingen, Germany) at the Center for High Technologies of BSTU named after V.G. Shukhov. For preparation of the studied samples, especially pure potassium bromide, which is absolutely transparent to IR radiation, was used. The test sample was mixed with potassium bromide, thoroughly ground, and the disks were pressed under a pressure of 7 tons prior to recording their IR spectra. The IR spectra of the investigated substances were recorded in the range from 400 to 3900 cm−1.
1H-NMR spectra were obtained on a TESLA BS 476A spectrometer with an operating frequency of 60 MHz (manufactured by Tesla, Czech Republic).
High-performance liquid chromatography (HPLC) analysis was used to determine the reaction products. Columns SEPARON SC-X C-18 were used. A RIDK 101 differential refractometer was used as a detector. Bidistilled water served as the eluent.
The molecular weight of the oligomers was determined by the cryoscopic method (Rast method) using a Beckman apparatus. The molecular weight was estimated by lowering the freezing point of a solution of the oligomer in dimethyl sulfoxide when compared with the freezing point of a pure solvent according to Formula (1):
M = K · g 2 · 1000 g 1 · Δ T
where g1 is the mass of dimethyl sulfoxide, g; g2 is the mass of the oligomer, g; K-cryoscopic constant for dimethyl sulfoxide, K = 4.7; ΔT is the freezing temperature difference.
The percent yield of the reaction was calculated by the Formula (2):
% Y i e l d = A c t u a l   Y i e l d T h e o r e t i c a l   Y i e l d   · 100 %
The ultimate compressive strength (MPa) of plasticized and unplasticized cement compositions was determined on 2 × 2 × 2 cm cubes. The specimens under study gained strength for 28 days. The samples were tested on a PSU-50 laboratory hydraulic press. The maximum pressure generated by the hydraulic press is 50 tons.

3. Results and Discussion

3.1. Study of the Products of the Interaction of 1,3,5-Trioxybenzene and 2-Furaldehyde with NaOH by UV Spectroscopy

From the literature [32] it is known that 2-furaldehyde enters into a disproportionation reaction in an alkaline medium according to the Cannizzaro reaction (Figure 2.) with the formation of two reaction products, sodium salt of 2-furancarboxylic acid and 2-furyl methyl alcohol.
To establish the features of the chemical reaction (condensation) between 2-furaldehyde and 1,3,5-trihydroxybenzene in an alkaline medium, we first studied the interaction of each component (monomer) with NaOH. The method of UV spectroscopy was used to record changes in the absorption maxima characteristic of monomers during their chemical interaction with alkali, which made it possible to determine the chemistry of the reaction. Figure 3 shows the initial and UV spectrum of the interaction of 1,3,5-trihydroxybenzene with NaOH at 70 °C. The solution was stirred for 25 min at 70 °C and afterwards the solution was kept at room temperature for 24 h.
Analysis of the UV spectra presented in Figure 3 showed that both spectra exhibit absorption maxima in the region of 203 nm, characteristic of 1,3,5-trihydroxybenzene. A shoulder is also observed in the region from 213 to 245 nm and an absorption maximum in the region of 276 nm. The results obtained indicate that 1,3,5-trihydroxybenzene does not react with NaOH.
The stability of the solution does not change. However, a change in the color of the solution was noticed upon the addition of NaOH; at first the solution had a light orange color, and after holding for 24 h it changed to a brown color. Perhaps the color change was due to the fact that NaOH improves the dissociation of 1,3,5-trihydroxybenzene molecules in water.
Figure 4 shows the UV spectrum of the control solution (2-furaldehyde aqueous solution) and the UV spectrum of the interaction of 2-furaldehyde with NaOH at 70 °C in the wavelength range from 190 to 500 nm. As in the previous experiment, the solution was stirred for 25 min at 70 °C, and afterwards, the solution was kept at room temperature for 24 h. In the control 2-furaldehyde aqueous solution, phase separation was observed where the bottom layer was 2-furaldehyde. No phase separation was observed in the solution with NaOH. The formation of a homogeneous solution of dark brown color was observed in which a faint smell of 2-furaldehyde was detected. The UV spectrum of the control solution (Figure 4a) and the solution with NaOH (Figure 4b) show an absorption maximum at 277 nm.
In the UV spectrum of the interaction of 2-furaldehyde with NaOH, new absorption maxima appear at 217 and 246 nm compared to the control solution, and the absorption maximum at 229 nm disappears. You can also notice that there is a decrease in optical density at a wavelength of 277 nm by three times compared with the control solution of the monomer.
Thus, based on the obtained UV spectroscopic data, it was found that 2-furaldehyde reacts with NaOH to form two products. It is known from the literature that the characteristic absorption maximum at a wavelength of 245 nm corresponds to 2-furancarboxylic acid and its salt, and the characteristic absorption maximum at a wavelength of 216 nm corresponds to 2-furyl methyl alcohol [33].

3.2. Study of the Product of the Interaction of 1,3,5-Trioxybenzene with 2-Furaldehyde in an Alkaline Medium by UV Spectroscopy

Since 2-furaldehyde undergoes disproportionation in an alkaline medium with the formation of two products, this reaction can interfere with the condensation reaction between 2-furaldehyde and 1,3,5-trihydroxybenzene in an alkaline medium. To establish the optimal method for the synthesis of a plasticizing additive based on 2-furaldehyde and 1,3,5-trihydroxybenzene, two parallel oligomer syntheses were carried out with different methods of adding the condensing agent. In the first solution, 2-furaldehyde was immediately introduced, and in the second, the same mass of 2-furaldehyde was added but only at a rate of 0.05 mL/min.
The UV spectrum of the first solution (Figure 5a), where the addition of the condensing agent was instantaneous, shows absorption maxima at 215 and 279 nm, which are characteristic of 2-furylmethyl alcohol and 2-furaldehyde, respectively. This suggests that the condensing agent did not fully enter into the condensation reaction with 1,3,5-trihydroxybenzene, and began to partially disproportionate with the formation of 2-furyl methyl alcohol. Additionally, on the UV spectrum, there is no absorption maximum characteristic of 2-furancarboxylic acid. This suggests that 2-furancarboxylic acid reacted with 1,3,5-trihydroxybenzene.
The UV spectrum of the second solution (Figure 5b), where the addition of the condensing agent was smooth and at a rate of 0.05 mL/min, shows absorption maxima at 208 and 286 nm, which are not characteristic of 2-furyl methyl alcohol and 2-furaldehyde. It can be argued that the condensing agent completely entered into a condensation reaction with 1,3,5-trihydroxybenzene to form 1,3,5-trihydroxybenzene-2-furaldehyde oligomer. Thus, it was found that in the complete course of the condensation reaction between 1,3,5-trihydroxybenzene and the condensing agent, 2-furaldehyde, occurs with the gradual introduction of the agent into the reaction mixture which allows you to get a better product. It can be assumed that the sodium salt of 2-furancarboxylic acid, formed as a result of disproportionation of 2-furaldehyde, increases the rate of crosslinking of the obtained oligomers in solution, which greatly affects the storage time and efficiency of the water-reducing agent.

3.3. Study of the Product of the Interaction of 1,3,5-Trioxybenzene with 2-Furaldehyde in an Alkaline Medium by IR Spectroscopy

To interpret the IR spectrum of the product of the interaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium, the IR spectra of the starting monomers were obtained: 2-furaldehyde (Figure 6) and 1,3,5-trihydroxybenzene (Figure 7).
The IR spectrum of 2-furaldehyde (Figure 6) exhibits weak stretching vibrations of the C–H bond in the range of 3200–2800 cm−1, which are characteristic of heterocyclic compounds. Skeletal vibrations of the molecule are also observed in the region of 1800–900 cm−1, and in the region 1600–1900 cm1 there are stretching vibrations of the C = O group that characterize this compound.
The IR spectrum of 1,3,5-trihydroxybenzene (Figure 7) shows internal and intermolecular H-bonds in the range of 3500–3000 cm−1, which are characteristic of phenols. In the region of 3400–3100 cm−1, stretching vibrations of hydroxyl groups are observed, and in the region of 1900–1400 cm−1, composite frequencies and overtones are concentrated, which determine the type of substitution in the benzene nucleus. The strongest part of absorption is in the region 1200–1100 cm−1, which is responsible for in-plane deformation vibrations of C-H bonds of 1,3-, 1,5-, 1,3,5-substituted positions. In a specific case, the IR spectrum corresponds to 1,3,5-substituted phenol.
The IR spectrum of the product of the interaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium is shown in Figure 8. The IR spectrum of the obtained oligomer clearly shows absorption bands of weak stretching vibrations of CH bonds in aromatic compounds (this indicates the addition of CH bonds of the heterocyclic ring to the benzene ring). In the range of 2900–2200 cm−1, the stretching vibrations of hydroxyl groups weaken.
Thus, as a result of the studies carried out, it was found that the condensation of 2-furaldehyde with 1,3,5-trihydroxybenzene in an alkaline medium forms a new substance-1,3,5-trihydroxybenzene-2-furaldehyde oligomer, which is confirmed by the IR spectrum of the obtained product (Figure 8). In the IR spectrum of the product of the interaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium (Figure 8), stronger C–H bonds appear, and stretching vibrations of the C = O group are not observed.

3.4. Investigation of the Product of the Interaction of 1,3,5-Trioxybenzene with 2-Furaldehyde in an Alkaline Medium by HPLC Analysis

Figure 9 shows a liquid chromatogram of a mixture of 1,3,5-trioxybenzene and 2-furaldehyde in water (Figure 9a), as well as a liquid chromatogram of the products obtained by condensation interaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium (Figure 9b). HPLC analysis showed that the peak at 7 min corresponds to the yield of 1,3,5-trioxybenzene and the peak at 9 min corresponds to the yield of 2-furaldehyde (Figure 9a). The area of the peaks was used to calculate the relative concentration of 1,3,5-trioxybenzene and 2-furaldehyde at different time stages of the reaction. The chromatograms show that at the beginning of the co-condensation reaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium, their mono derivatives are formed (peak 3 in Figure 9b). After 40–50 min (Figure 9c), a further change in the molecular structure occurs, as evidenced by a decrease in peak 3 (mono derivatives) and peak 1 (the remaining 1,3,5-trioxybenzene) and the appearance of peak 4 at 11 min, corresponding to oligomeric molecules, which are better adsorbed on this sorbent and, therefore, leave the column later.
HPLC analysis showed that by the end of the reaction (after 90 min of synthesis), with the gradual introduction of a condensing agent, 1,3,5-trioxybenzene reacted in an amount of 70.0 wt.%, and 2-furaldehyde in the amount of 97.0 wt.%.

3.5. Study of the Product of the Interaction of 1,3,5-Trioxybenzene with 2-Furaldehyde in an Alkaline Medium by NMR Spectroscopy

Figure 10 shows the 1H-NMR spectrum of a mechanical mixture of 1,3,5-trioxybenzene and 2-furaldehyde, as well as the reaction product obtained by condensation reaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium.
On the 1H-NMR spectrum of a mechanical mixture of 1,3,5-trioxybenzene and 2-furaldehyde (Figure 10a) in the range of 9–10 ppm there is a peak formed as a result of the resonance of aldehyde protons of 2-furaldehyde (1). In the course of the condensation reaction, by taking the integral curves, the dependence of the area of this peak on the reaction time was determined. The change in area corresponds to a change in the relative concentration of the aldehyde proton in the reaction mixture.
Studies of 1H-NMR spectra of condensation products at certain time intervals showed that as a result of the reaction, the signal of 9.0–10.0 ppm gradually disappears, corresponding to the protons of the aldehyde group of 2-furaldehyde, and a new peak appears in the region of 3.0 ppm, indicating about the formation of-C–OH-groups (5,6) (Figure 10b). A decrease in the signals of aromatic protons of 5.5–5.8 ppm (4) indicates the binding of molecules into oligomers and a decrease in the degree of mobility of the remaining protons. With condensation, the shape of the peak in the range of 8.0–8.3 ppm changed, corresponding to the protons of the –OH groups of 1,3,5-trioxybenzene, its splitting was observed, which corresponds to a change in the influence of neighboring protons as a result of the appearance of additional substituents in aromatic rings 1, 3,5-trioxybenzene with the formation of bonds (6), and subsequently (5).
Comparative analysis of integral curves of the 1H-NMR spectrum the product of the reaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium gave the following ratio of protons-protons of 1,3,5-trioxybenzene rings and 2-furaldehyde: OH-group protons: CH-group protons ≈1.5:2.5:1. This made it possible to determine the most probable oligomer molecule.
The scheme of the joint condensation of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium with the formation of oligomers is shown in Figure 11.
The yield of the reaction product was calculated using the formula (2). When calculating the “Actual Yield” value, the quantitative data of the reacted substances were taken into account. According to HPLC analysis, 1,3,5-trioxybenzene reacted in the amount of 70.0 wt.%, and 2-furaldehyde in the amount of 97.0 wt.%. Thus, the yield of 1,3,5-trihydroxybenzene-2-furaldehyde oligomer was 89.2 wt.%. The average molecular weight of 1,3,5-trihydroxybenzene-2-furaldehyde oligomer calculated by the Rast method is 1200 ± 30.

3.6. Determination of the Plasticizing Ability of 1,3,5-Trihydroxybenzene-2-furaldehyde Oligomer

Determination of the plasticizing ability of 1,3,5-trihydroxybenzene-2-furaldehyde oligomer and its optimal dosage was carried out by determining the diameter of the mini-cone spread according to the method developed at the Scientific Research, Design and Technological Institute of Concrete and Reinforced Concrete named after A. A. Gvozdev in Russia. The process for determining the plasticizing ability is shown schematically in Figure 12. The cement paste is loaded into a mini-cone, then it is raised and the diameter of the spreading mixture is measured.
A series of cement pastes with the addition of the investigated plasticizing additive in the amount of 0.1; 0.2; 0.3; 0.4% by weight of cement (calculated on dry matter) were prepared. In this case, the water-cement ratio in all experiments was the same 0.4. Figure 13 shows the data of the dependence of the diameter of the mini-cone spreading on the dosage of 1,3,5-trihydroxybenzene-2-furaldehyde.
Analysis of the data presented in Figure 13 showed that the diameter of the spreading of the cement paste of the unplasticized system (without the addition of a plasticizing additive) is 4.5 cm. In the presence of the additive, a significant dilution of the cement paste is observed. An increase in the spreading diameter of the mini-cone of the plasticized system of up to 19 cm determines the value of the plasticizing ability of the synthesized oligomer. The minimum dosage of 1,3,5-trihydroxybenzene-2-furaldehyde at which the maximum plasticizing effect is achieved is 0.3% of the cement mass, which characterizes the plasticizing activity of the additive. Thus, the optimal dosage of the developed plasticizing additive is 0.3% of the cement weight (calculated on dry matter).
Table 1 presents data on the mechanical characteristics of cement compositions using 1,3,5-trihydroxybenzene-2-furaldehyde additives.
Analysis of the data in Table 1 showed that the use of the developed plasticizing additive of 1,3,5-trihydroxybenzene-2-furaldehyde in an amount of 0.3% (by weight of dry matter) can significantly reduce the water-cement ratio while maintaining increased mobility and obtaining increased strength characteristics of cement compositions. In addition, the results obtained show the possibility of using the synthesized additive to obtain SCC.

4. Conclusions

The paper presents the possibility of synthesizing a plasticizing additive based on 2-furaldehyde and 1,3,5-trihydroxybenzene, and also presents the chemistry of the reaction between the components.
It was found that 1,3,5-trihydroxybenzene does not react with NaOH, while 2-furaldehyde reacts with NaOH to form two products. The characteristic absorption maximum at a wavelength of 245 nm corresponds to 2-furancarboxylic acid and its salt, and the characteristic absorption maximum at a wavelength of 216 nm corresponds to 2-furyl methyl alcohol.
As a result of the work, it was revealed that to obtain 1,3,5-trihydroxybenzene-2-furaldehyde oligomer, a gradual introduction of a condensing agent (2-furaldehyde) at a rate of 0.05 mL/min is required. With the instant addition of a condensing agent, absorption maxima are observed in the region of 215 and 279 nm, which are characteristic of 2-furyl methyl alcohol and 2-furaldehyde, respectively. This indicates that the condensing agent did not completely enter into a condensation reaction with 1,3,5-trihydroxybenzene, and began to partially disproportionate with the formation of 2-furylmethyl alcohol.
Comparative analysis of integral curves of the 1H-NMR spectrum the product of the reaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium gave the following ratio of protons-protons of 1,3,5-trioxybenzene rings and 2-furaldehyde: OH-group protons: CH-group protons ≈ 1.5:2.5:1.
The optimal dosage of the developed plasticizing additive is 0.3% of the cement weight (calculated on dry matter). The developed plasticizing additive can significantly reduce the water-cement ratio while maintaining increased mobility and obtaining increased strength characteristics of cement compositions.

Author Contributions

Conceptualization, V.A.P. and S.A.S.; methodology, validation, V.A.P. and N.I.C.; formal analysis, N.I.C.; investigation, D.S.R.; writing—original draft preparation, N.I.C.; writing—review and editing, S.A.S.; supervision, N.I.C.; funding acquisition, N.I.C. All authors have read and agreed to the published version of the manuscript.

Funding

The work is realized using equipment of High Technology Center at BSTU named after V.G. Shukhov the framework of the State Assignment of the Ministry of Education and Science of the Russian Federation, project No. FZWN-2021-0015.

Conflicts of Interest

The authors declare no conflict of interest. The funders had no role in the design of the study; in the collection, analyses, or interpretation of data; in the writing of the manuscript, or in the decision to publish the results.

References

  1. Mazurok, P.; Turgunov, T.; Svidersky, V.; Tokarchuk, V. Oil Well Cement Additives: A Review of the Common Types. Oil Gas Res. 2016, 2, 112. [Google Scholar]
  2. Svintsov, A.P.; Shchesnyak, E.L.; Galishnikova, V.V.; Fediuk, R.S.; Stashevskaya, N.A. Effect of nano-modified additives on properties of concrete mixtures during winter season. Constr. Build. Mater. 2020, 237, 117527. [Google Scholar] [CrossRef]
  3. Shi, J.; Fan, W.; Lin, Y.; Zhao, P.; Ouyang, J. Effects of Surfactant Warm-Mix Additives on the Rheological Properties of High-Viscosity Asphalt. Adv. Mater. Sci. Eng. 2020, 2020, 6506938. [Google Scholar] [CrossRef] [Green Version]
  4. Zhang, S.; Qiao, W.; Li, Y.; Xi, K.; Chen, P. Effect of Additives on the Rheological and Mechanical Properties of Micro-fine-Cement-Based Grout. Adv. Mater. Sci. Eng. 2019, 2019, 1931453. [Google Scholar] [CrossRef] [Green Version]
  5. Frąc, M.; Szudek, W.; Szołdra, P.; Pichór, W. The applicability of shungite as an electrically conductive additive in cement composites. J. Build. Eng. 2021, 45, 103469. [Google Scholar] [CrossRef]
  6. Konkol, J. Fracture Toughness and Fracture Surface Morphology of Concretes Modified with Selected Additives of Pozzolanic Properties. Buildings 2019, 9, 174. [Google Scholar] [CrossRef] [Green Version]
  7. Pavon, C.; Aldas, M.; López-Martínez, J.; Ferrándiz, S. New Materials for 3D-Printing Based on Polycaprolactone with Gum Rosin and Beeswax as Additives. Polymers 2020, 12, 334. [Google Scholar] [CrossRef] [Green Version]
  8. Breilly, D.; Fadlallah, S.; Froidevaux, V.; Colas, A.; Allais, F. Origin and industrial applications of lignosulfonates with a focus on their use as superplasticizers in concrete. Constr. Build. Mater. 2021, 301, 124065. [Google Scholar] [CrossRef]
  9. Zhang, Z.; Li, Y.; Ren, L.; Guo, Z.; Jiang, H.; Liu, N. Evaluation of Rheological Parameters of Slag-Based Paste Backfill with Superplasticizer. Adv. Mater. Sci. Eng. 2021, 2021, 6673033. [Google Scholar] [CrossRef]
  10. Papo, A.; Piani, L.; Ricceri, R. Rheological Properties of Very High-Strength Portland Cement Pastes: Influence of Very Effective Superplasticizers. Int. J. Chem. Eng. 2010, 2010, 682914. [Google Scholar] [CrossRef] [Green Version]
  11. Gupta, N.; Gupta, A.; Saxena, K.K.; Shukla, A.; Goyal, S.K. Mechanical and durability properties of geopolymer concrete composite at varying superplasticizer dosage. Mater. Today Proc. 2020, 44, 12–16. [Google Scholar] [CrossRef]
  12. Chakkamalayath, J.; Santhanam, M.; Gettu, R. Cement-superplasticiser compatibility—Issues and challenges. Indian Concr. J. 2021, 85, 48–60. [Google Scholar]
  13. Wu, Y.; Li, Q.; Li, G.; Tang, S.; Niu, M.; Wu, Y. Effect of Naphthalene-Based Superplasticizer and Polycarboxylic Acid Super-plasticizer on the Properties of Sulfoaluminate Cement. Materials 2021, 14, 662. [Google Scholar] [CrossRef]
  14. Coppola, L.; Lorenzi, S.; Kara, P.; Garlati, S. Performance and Compatibility of Phosphonate-Based Superplasticizers for Concrete. Buildings 2017, 7, 62. [Google Scholar] [CrossRef] [Green Version]
  15. Hekal, E.E.; Kishar, E.A. Effect of sodium salt of naphthalene-formaldehyde polycondensate on ettringite formation. Cem. Concr. Res. 1999, 29, 1535–1540. [Google Scholar] [CrossRef]
  16. Wang, H.; Yang, X.; Xiong, W.; Liu, X.; Zhang, Z. Synthesis and the Effects of New Melamine Superplasticizer on the Properties of Concrete. ISRN Chem. Eng. 2013, 2013, 708063. [Google Scholar] [CrossRef]
  17. Essam, A.; Ahmed, D.A.E.M.; Hegazy, W.S. Hydration reactions of the system C3A-CaSO4.2H2O (1:1 mole ratio) at 30 and 50 °C. Part II: Effect of naphthalene formaldehyde sulfonate. Adv. Cem. Res. 2011, 23, 123–128. [Google Scholar] [CrossRef]
  18. Chen, S.; Zhang, J.; Sun, S.; Zhong, K.; Shao, Q.; Xu, H.; Huang, H.; Wei, J. Dispersion, fluidity retention and retardation effect of polyacrylate-based ether superplasticizer nanomicelles in Portland cement. Constr. Build. Mater. 2021, 290, 123149. [Google Scholar] [CrossRef]
  19. Zhang, R.; Li, Q.; Zhang, A.; Liu, Y.; Lei, J. The synthesis technique of polyacrylic acid superplasticizer. J. Wuhan Univ. Technol. Sci. Ed. 2008, 23, 830–833. [Google Scholar] [CrossRef]
  20. Lin, X.; Pang, H.; Wei, D.; Lu, M.; Liao, B. Effect of superplasticizers with different anchor groups on the properties of cementitious systems. Colloids Surf. A Physicochem. Eng. Asp. 2021, 630, 127207. [Google Scholar] [CrossRef]
  21. Tian, H.; Kong, X.; Su, T.; Wang, D. Comparative study of two PCE superplasticizers with varied charge density in Portland cement and sulfoaluminate cement systems. Cem. Concr. Res. 2018, 115, 43–58. [Google Scholar] [CrossRef]
  22. Stecher, J.; Plank, J. Novel concrete superplasticizers based on phosphate esters. Cem. Concr. Res. 2019, 119, 36–43. [Google Scholar] [CrossRef]
  23. Xiang, S.; Gao, Y.; Shi, C. Progresses in Synthesis of Polycarboxylate Superplasticizer. Adv. Civ. Eng. 2020, 2020, 8810443. [Google Scholar] [CrossRef]
  24. Dalas, F.; Pourchet, S.; Nonat, A.; Rinaldi, D.; Sabio, S.; Mosquet, M. Fluidizing efficiency of comb-like superplasticizers: The effect of the anionic function, the side chain length and the grafting degree. Cem. Concr. Res. 2015, 71, 115–123. [Google Scholar] [CrossRef]
  25. Ren, Q.; Zou, H.; Liang, M.; Wang, Y.; Wang, J. Preparation and characterization of amphoteric polycarboxylate and the hydration mechanism study used in portland cement. RSC Adv. 2014, 4, 44018–44025. [Google Scholar] [CrossRef]
  26. Akhlaghi, O.; Menceloglu, Y.Z.; Akbulut, O. Poly(carboxylate ether)-based superplasticizer achieves workability retention in calcium aluminate cement. Sci. Rep. 2017, 7, 201–224. [Google Scholar] [CrossRef] [Green Version]
  27. Zhu, J.; Hui, J.; Luo, H.; Zhang, B.; Wei, X.; Wang, F.; Li, Y. Effects of polycarboxylate superplasticizer on rheological properties and early hydration of natural hydraulic lime. Cem. Concr. Compos. 2021, 122, 104052. [Google Scholar] [CrossRef]
  28. Boota, M.; Parans Paranthaman, M.; Naskar, A.K.; Li, Y.; Akato, K.; Gogotsi, Y. Waste Tire Derived Carbon-Polymer Com-posite Paper as Pseudocapacitive Electrode with Long Cycle Life. ChemSusChem 2015, 12, 43–66. [Google Scholar]
  29. Bond, J.Q.; Upadhye, A.A.; Olcay, H.; Tompsett, G.A.; Jae, J.; Xing, R. Synthesis of Furfural from Water Hyacinth (Eichornia croassipes). IOP Conf. Ser. Mater. Sci. Eng. 2014, 7, 1500–1523. [Google Scholar]
  30. Mukherjee, A.; Portillo-Perez, G.; Dumont, M.J. Synthesis of hydroxymethylfurfural and furfural from hardwood and soft-wood pulp using ferric sulphate as catalyst. Front. Chem. Sci. Eng. 2019, 13, 531–542. [Google Scholar] [CrossRef]
  31. Poluektova, V.A.; Kozhanova, E.P.; Kudina, A.E. Adsorption of phloroglucinfurfural oligomers on the surface of polymer mineral dispersions. Bull. Belgorod State Technol. Univ. 2017, 10, 116–122. [Google Scholar]
  32. Roselli, A.; Carvalho, Y.; Dumeignil, F.; Cavani, F.; Paul, S.; Wojcieszak, R. Liquid Phase Furfural Oxidation under Un-controlled pH in Batch and Flow Conditions: The Role of In Situ Formed Base. Catalysts 2020, 10, 73. [Google Scholar] [CrossRef] [Green Version]
  33. Kenzo, H. Handbook of Ultraviolet and Visible Absorption Spectra of Organic Compounds; Plenum Press Data Division: New York, NY, USA, 1967; 642p. [Google Scholar]
Figure 1. Structural formula: (a) 1,3,5-trioxybenzene; (b) 2-furaldehyde.
Figure 1. Structural formula: (a) 1,3,5-trioxybenzene; (b) 2-furaldehyde.
Chemengineering 05 00084 g001
Figure 2. Disproportionation reaction of 2-furaldehyde (Cannizzaro reaction).
Figure 2. Disproportionation reaction of 2-furaldehyde (Cannizzaro reaction).
Chemengineering 05 00084 g002
Figure 3. UV spectra of 1,3,5-trihydroxybenzene: (a) initial; (b) after interaction with NaOH at a temperature of 70 °C and holding for 24 h.
Figure 3. UV spectra of 1,3,5-trihydroxybenzene: (a) initial; (b) after interaction with NaOH at a temperature of 70 °C and holding for 24 h.
Chemengineering 05 00084 g003
Figure 4. UV spectra of 2-furaldehyde: (a) control solution; (b) interaction with NaOH.
Figure 4. UV spectra of 2-furaldehyde: (a) control solution; (b) interaction with NaOH.
Chemengineering 05 00084 g004
Figure 5. UV spectrum of the synthesized oligomer: (a) with instant addition of the condensing agent; (b) with smooth introduction of the condensing agent.
Figure 5. UV spectrum of the synthesized oligomer: (a) with instant addition of the condensing agent; (b) with smooth introduction of the condensing agent.
Chemengineering 05 00084 g005
Figure 6. IR spectrum of 2-furaldehyde.
Figure 6. IR spectrum of 2-furaldehyde.
Chemengineering 05 00084 g006
Figure 7. IR spectrum of 1,3,5-trihydroxybenzene.
Figure 7. IR spectrum of 1,3,5-trihydroxybenzene.
Chemengineering 05 00084 g007
Figure 8. IR spectrum of the product of the interaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium.
Figure 8. IR spectrum of the product of the interaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium.
Chemengineering 05 00084 g008
Figure 9. Liquid chromatogram of a mixture of 1,3,5-trioxybenzene and 2-furaldehyde in water (a) and the reaction mixture after 20 min (b) and 40 min (c): 1-peak of 1,3,5-trioxybenzene; 2-peak of 2-furaldehyde; 3-mono derivatives of phloroglucinol and furfural; 4-oligomers.
Figure 9. Liquid chromatogram of a mixture of 1,3,5-trioxybenzene and 2-furaldehyde in water (a) and the reaction mixture after 20 min (b) and 40 min (c): 1-peak of 1,3,5-trioxybenzene; 2-peak of 2-furaldehyde; 3-mono derivatives of phloroglucinol and furfural; 4-oligomers.
Chemengineering 05 00084 g009
Figure 10. 1H-NMR spectra (a) a mechanical mixture of 1,3,5-trioxybenzene and 2-furaldehyde; (b) the product of the interaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium: 1-protons of the aldehyde group of 2-furaldehyde; 2-protons of the furan ring; 3-protons of OH groups of 1,3,5-trioxybenzene; 4-protons of aromatic rings of 1,3,5-trioxybenzene; 5-methine protons (CH); 6-OH groups.
Figure 10. 1H-NMR spectra (a) a mechanical mixture of 1,3,5-trioxybenzene and 2-furaldehyde; (b) the product of the interaction of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium: 1-protons of the aldehyde group of 2-furaldehyde; 2-protons of the furan ring; 3-protons of OH groups of 1,3,5-trioxybenzene; 4-protons of aromatic rings of 1,3,5-trioxybenzene; 5-methine protons (CH); 6-OH groups.
Chemengineering 05 00084 g010
Figure 11. Scheme of the joint condensation of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium.
Figure 11. Scheme of the joint condensation of 1,3,5-trioxybenzene with 2-furaldehyde in an alkaline medium.
Chemengineering 05 00084 g011
Figure 12. Schematic process for determining the plasticizing ability of additives for cement systems.
Figure 12. Schematic process for determining the plasticizing ability of additives for cement systems.
Chemengineering 05 00084 g012
Figure 13. Dependence of the diameter of the mini-cone spreading on the dosage of 1,3,5-trihydroxybenzene-2-furaldehyde.
Figure 13. Dependence of the diameter of the mini-cone spreading on the dosage of 1,3,5-trihydroxybenzene-2-furaldehyde.
Chemengineering 05 00084 g013
Table 1. Mechanical characteristics of cement compositions using 1,3,5-trihydroxybenzene-2-furaldehyde additive.
Table 1. Mechanical characteristics of cement compositions using 1,3,5-trihydroxybenzene-2-furaldehyde additive.
Content of Plasticizing Additive, %Water-Cement RatioMini-Cone Spreading Diameter, cmCompressive Strength 28 Days, MPa
-0.44.558.6
0.30.41958.2
0.30.31067.5
0.30.452056.2
Publisher’s Note: MDPI stays neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Share and Cite

MDPI and ACS Style

Poluektova, V.A.; Cherkashina, N.I.; Starchenko, S.A.; Romanyuk, D.S. Features of the Chemical Interaction of 2-Furaldehyde and 1,3,5-Trihydroxybenzene in an Alkaline Medium to Obtain a Plasticizing Additive. ChemEngineering 2021, 5, 84. https://doi.org/10.3390/chemengineering5040084

AMA Style

Poluektova VA, Cherkashina NI, Starchenko SA, Romanyuk DS. Features of the Chemical Interaction of 2-Furaldehyde and 1,3,5-Trihydroxybenzene in an Alkaline Medium to Obtain a Plasticizing Additive. ChemEngineering. 2021; 5(4):84. https://doi.org/10.3390/chemengineering5040084

Chicago/Turabian Style

Poluektova, Valentina Anatolyevna, Natalia Igorevna Cherkashina, Sergey Aleksandrovich Starchenko, and Dmitriy Sergeevich Romanyuk. 2021. "Features of the Chemical Interaction of 2-Furaldehyde and 1,3,5-Trihydroxybenzene in an Alkaline Medium to Obtain a Plasticizing Additive" ChemEngineering 5, no. 4: 84. https://doi.org/10.3390/chemengineering5040084

Article Metrics

Back to TopTop