Top

Tribology Letters

Published in:

01-10-2010 | Original Paper

Tribological Properties of a Nano-Eutectic Fe_1.87C_0.13 Alloy Under Water Environment

Authors: Lin Wang, Jun Yang, Jiqiang Ma, Qinling Bi, Licai Fu, Junying Hao, Weimin Liu

Published in: Tribology Letters | Issue 1/2010

Activate our intelligent search to find suitable subject content or patents.

search-config

AI-assisted search

Off

Abstract

Tribological properties of a nano-eutectic Fe_1.87C_0.13 alloy were investigated under distilled-water lubrication against AISI52100 steel ball for various applied loads and sliding speeds. For comparison, the tribological behavior of annealed coarse-grained Fe_1.87C_0.13 alloy was also examined under the same testing conditions. Worn surfaces of both alloys were analyzed by using a scanning electron microscope (SEM). The wear rate of nano-eutectic Fe_1.87C_0.13 alloy was on the order of 10⁻⁵ mm³/m. The wear rate of nano-eutectic Fe_1.87C_0.13 alloy was higher than that of annealed Fe_1.87C_0.13 alloy at lower load, but lower under higher load. The friction coefficients of the two alloys were similar and exhibited a slight increase with increasing sliding speed, but a small decrease with increasing applied load. The wear mechanism of the nano-eutectic Fe_1.87C_0.13 alloy was transformed from plowing and corrosion wear to slight fatigue cracking with increasing applied load, whereas that of the annealed coarse-grained Fe_1.87C_0.13 alloy was transformed from plowing and corrosion wear to severe fatigue flaking.

previous article Thickness Change in Molecularly Thin Lubricant Under Flying Head in Hard Disk Drives

next article A Generalised Asperity-Based Friction Model

Dont have a licence yet? Then find out more about our products and how to get one now:

Springer Professional "Wirtschaft+Technik"

Online-Abonnement

Mit Springer Professional "Wirtschaft+Technik" erhalten Sie Zugriff auf:

über 102.000 Bücher
über 537 Zeitschriften

aus folgenden Fachgebieten:

Automobil + Motoren
Bauwesen + Immobilien
Business IT + Informatik
Elektrotechnik + Elektronik
Energie + Nachhaltigkeit
Finance + Banking
Management + Führung
Marketing + Vertrieb
Maschinenbau + Werkstoffe
Versicherung + Risiko

Jetzt Wissensvorsprung sichern!

inform now

Springer Professional "Technik"

Online-Abonnement

Mit Springer Professional "Technik" erhalten Sie Zugriff auf:

über 67.000 Bücher
über 390 Zeitschriften

aus folgenden Fachgebieten:

Automobil + Motoren
Bauwesen + Immobilien
Business IT + Informatik
Elektrotechnik + Elektronik
Energie + Nachhaltigkeit
Maschinenbau + Werkstoffe

Jetzt Wissensvorsprung sichern!

inform now

Koch, C.C., Ovid’ko, I.A., Seal, S., Veprek, S.: Structural nanocrystalline materials fundamentals and applications. Cambridge University Press, New York (2007)CrossRef

Meyers, M.A., Mishra, A., Benson, D.J.: Mechanical properties of nanocrystalline materials. Prog. Mater. Sci. 51, 427–556 (2006). doi:10.1016/j.pmatsci.2005.08.003 CrossRef

Kumar, K.S., Swygenhoven, H.V., Suresh, S.: Mechanical behavior of nanocrystalline metals and alloys. Acta Mater. 51, 5743–5774 (2003). doi:10.1016/j.actamat.2003.08.032 CrossRef

Han, Z., Zhang, Y.S., Lu, K.: Friction and wear behaviors of nanostructured metals. J. Mater. Sci. Technol. 24, 483–494 (2008)

Zhang, Y.S., Wang, K., Han, Z., Liu, G.: Dry sliding wear behavior of copper with nano-scaled twins. Wear 262, 1463–1470 (2007). doi:10.1016/j.wear.2007.01.012 CrossRef

Panagopoulos, C.N., Georgarakis, K.G., Anagnostopoulou, A.: The influence of grain size on the sliding wear behaviour of zinc. Mater. Lett. 60, 133–136 (2006). doi:10.1016/j.matlet.2005.08.003 CrossRef

Fu, L.C., Yang, J., Bi, Q.L., Zhu, S.Y., Liu, W.M.: Dry-sliding tribological properties of nano-eutectic Fe₈₃B₁₇ alloy. Tribol. Lett. 34, 185–191 (2009). doi:10.1007/s11249-009-9422-x CrossRef

Shafiei, M., Alpas, A.T.: Effect of sliding speed on friction and wear behaviour of nanocrystalline nickel tested in an argon atmosphere. Wear 265, 429–438 (2008). doi:10.1016/j.wear.2007.11.022 CrossRef

Wang, L., Ma, J.Q., Yang, J., Bi, Q.L., Fu, L.C., Liu, W.M.: Dry-sliding tribological properties of a nano-eutectic Fe_1.87C_0.13 alloy. Wear 268, 991–995 (2010). doi:10.1016/j.wear.2009.12.028 CrossRef

10.

Yang, J., Ma, J.Q., Bi, Q.L., Liu, W.M., Xue, Q.J.: Tribological properties of Fe₃Al material under water environment. Mater. Sci. Eng. A 490, 90–94 (2008). doi:10.1016/j.msea.2008.01.024 CrossRef

11.

Ma, J.Q., Hao, J.Y., Bi, Q.L., Fu, L.C., Yang, J., Liu, W.M.: Tribological properties of a Fe₃Al material in sulfuric acid corrosive environment. Wear 268, 264–268 (2010). doi:10.1016/j.wear.2009.07.018 CrossRef

12.

Zhang, Y.S., Wang, K., Han, Z., Lu, K.: Transfer behavior in low-amplitude oscillating wear of nanocrystalline copper under oil lubrication. J. Mater. Res. 23, 150–159 (2008). doi:10.1557/JMR.2008.0034 CrossRefADS

13.

Zhang, Y.S., Han, Z.: Fretting wear behavior of nanocrystalline surface layer of pure copper under oil lubrication. Tribol. Lett. 27, 53–59 (2007). doi:10.1007/s11249-007-9204-2 CrossRef

14.

Wang, L., Yang, J., Bi, Q.L., Ma, J.Q., Fu, L.C., Liu, W.M.: The tribological properties of a nano-eutectic Fe_1.87C_0.13 alloy under liquid paraffine lubrication. Tribol. Lett. 37, 183–189 (2010). doi:10.1007/s11249-009-9513-8 CrossRef

15.

Wang, J.Z., Yan, F.Y., Xue, Q.J.: Friction and wear behavior of ultra-hHigh molecular weight polyethylene sliding against GCr15 steel and electroless Ni–P alloy coating under the lubrication of seawater. Tribol. Lett. 35, 85–95 (2009). doi:10.1007/s11249-009-9435-5 CrossRefADS

16.

Yang, J., Ma, J.Q., Liu, W.M., Bi, Q.L., Xue, Q.J.: Large-scale Fe-C nanoeutectic alloy prepared by a self-propagating high-temperature synthesis casting route. Scripta Mater. 58, 1074–1077 (2008). doi:10.1016/j.scriptamat.2008.02.001 CrossRef

17.

Zhou, L., Liu, G., Han, Z., Lu, K.: Grain size effect on wear resistance of a nanostructured AISI52100 steel. Scripta Mater. 58, 445–448 (2008). doi:10.1016/j.scriptamat.2007.10.034 CrossRef

18.

Archard, J.F.: Contact and rubbing of flat surfaces. J. Appl. Phys. 24, 981–988 (1953). doi:10.1063/1.1721448 CrossRefADS

19.

Yang, J., La, P.Q., Liu, W.M., Xue, Q.J.: Tribological properties of FeAl intermetallics under dry sliding. Wear 257, 104–109 (2004). doi:10.1016/j.wear.2003.10.012 CrossRef

Title: Tribological Properties of a Nano-Eutectic Fe1.87C0.13 Alloy Under Water Environment
Authors: Lin Wang
Jun Yang
Jiqiang Ma
Qinling Bi
Licai Fu
Junying Hao
Weimin Liu
Publication date: 01-10-2010
Publisher: Springer US
Published in: Tribology Letters / Issue 1/2010
Print ISSN: 1023-8883
Electronic ISSN: 1573-2711
DOI: https://doi.org/10.1007/s11249-010-9644-y

Springer Professional

Abstract

Please log in to get access to your license.

Dont have a licence yet? Then find out more about our products and how to get one now:

Springer Professional "Wirtschaft+Technik"

Springer Professional "Technik"

Other articles of this Issue 1/2010

Positron Studies of Subsurface Zone Created in Sliding Wear in Bismuth

Tribological and Mechanical Characterization of Carbon-Coated Sliders and Disks

A Tribute to Professor James Lauer

Coupled Effect of Filler Content and Countersurface Roughness on PTFE Nanocomposite Wear Resistance

Adhesion Between Surfaces Separated by Molecularly Thin Perfluoropolyether Films

Tribological Behaviour of Orthopaedic Ti-13Nb-13Zr and Ti-6Al-4V Alloys

Premium Partners