nach oben

Erschienen in:

26.08.2022 | Original Article

Effectiveness of using water-extracted Leucaena leucocephala seeds as a coagulant for turbid water treatment: effects of dosage, pH, mixing speed, mixing time, and settling time

verfasst von: Mohammad Mohammad Alnawajha, Siti Rozaimah Sheikh Abdullah, Hassimi Abu Hasan, Ahmad Razi Othman, Setyo Budi Kurniawan

Erschienen in: Biomass Conversion and Biorefinery | Ausgabe 10/2024

Einloggen

Aktivieren Sie unsere intelligente Suche, um passende Fachinhalte oder Patente zu finden.

search-config

KI-gestützte Suche

Aus

Abstract

Natural materials have a high potential to be used as coagulant/flocculant owing to the problems of inorganic materials. Petai belalang (Leucaena leucocephala) is a widely abundant plant in Malaysia and very efficient as a plant-based coagulant in previous research. This research investigated the effectiveness of seeds of L. leucocephala in removing turbidity from synthetic wastewater and the effect of operation parameters of jar test on treatment performance through optimization of dosage, pH, rapid mixing speed and time, slow mixing speed and time, and settling time. The water extraction method was used to extract the active ingredients from the seeds by drying and pulverizing the seeds and then dissolving them in distilled water at a concentration of 20 g/L. The extraction solution of the seeds gives removal efficiency of turbidity of 93.05% at the optimum operation parameters dosage, pH, rapid mixing speed and time, slow mixing speed and time, and settling time of 120 mg/L, 6.5, 260 rpm for 11 min, 30 rpm for 15 min, and 30 min, respectively. It is expected that bridging was the possible mechanism given that the flocs are formed under the same negative zeta potential condition. With this high performance of L. leucocephala, it has high potential to be used as a coagulant in wastewater treatment at specific operation parameters with further exploration to determine the optimum extraction method of the active ingredients.

Vorheriger Artikel Preventing the deterioration of mechanical properties of polylactic acid/biomass composites via wet torrefaction

Nächster Artikel Xylooligosaccharide production by optimized sulfuric, acetic acid, and liquid hot water treatment of sugarcane leaves

Sie haben noch keine Lizenz? Dann Informieren Sie sich jetzt über unsere Produkte:

Springer Professional "Wirtschaft+Technik"

Online-Abonnement

Mit Springer Professional "Wirtschaft+Technik" erhalten Sie Zugriff auf:

über 102.000 Bücher
über 537 Zeitschriften

aus folgenden Fachgebieten:

Automobil + Motoren
Bauwesen + Immobilien
Business IT + Informatik
Elektrotechnik + Elektronik
Energie + Nachhaltigkeit
Finance + Banking
Management + Führung
Marketing + Vertrieb
Maschinenbau + Werkstoffe
Versicherung + Risiko

Jetzt Wissensvorsprung sichern!

Jetzt informieren

Springer Professional "Technik"

Online-Abonnement

Mit Springer Professional "Technik" erhalten Sie Zugriff auf:

über 67.000 Bücher
über 390 Zeitschriften

aus folgenden Fachgebieten:

Automobil + Motoren
Bauwesen + Immobilien
Business IT + Informatik
Elektrotechnik + Elektronik
Energie + Nachhaltigkeit
Maschinenbau + Werkstoffe

Jetzt Wissensvorsprung sichern!

Jetzt informieren

Bhargava A (2016) Physico-chemical waste water treatment technologies: an overview. Int J Sci Res Educ 4:5308–5319

Ighalo JO, Kurniawan SB, Iwuozor KO et al (2022) A review of treatment technologies for the mitigation of the toxic environmental effects of acid mine drainage (AMD). Process Saf Environ Prot 157:37–58. https://doi.org/10.1016/j.psep.2021.11.008CrossRef

Igwegbe CA, Obiora-Okafo IA, Iwuozor KO et al (2022) Treatment technologies for bakers’ yeast production wastewater. Environ Sci Pollut Res 29:11004–11026. https://doi.org/10.1007/s11356-021-17992-4CrossRef

Ghernaout D, Ghernaout B (2012) Sweep flocculation as a second form of charge neutralisation—a review. Desalin Water Treat 44:15–28CrossRef

Saritha V, Srinivas N, Srikanth Vuppala NV (2017) Analysis and optimization of coagulation and flocculation process. Appl Water Sci 7:451–460. https://doi.org/10.1007/s13201-014-0262-yCrossRef

Ahmad A, Kurniawan SB, Abdullah SRS et al (2022) Contaminants of emerging concern (CECs) in aquaculture effluent: Insight into breeding and rearing activities, alarming impacts, regulations, performance of wastewater treatment unit and future approaches. Chemosphere 290:133319. https://doi.org/10.1016/j.chemosphere.2021.133319CrossRef

Kurniawan SB, Abdullah SRS, Imron MF et al (2020) Challenges and opportunities of biocoagulant/bioflocculant application for drinking water and wastewater treatment and its potential for sludge recovery. Int J Environ Res Public Health 17:1–33. https://doi.org/10.3390/ijerph17249312CrossRef

Tzoupanos ND, Zouboulis a I (2008) Coagulation-flocculation processes in water / wastewater treatment : the application of new generation of chemical reagents. In: 6th IASME/WSEAS International Conference on heat transfer, thermal engineering and environment. pp 309–317

Kurniawan SB, Abdullah SRS, Othman AR et al (2021) Isolation and characterisation of bioflocculant-producing bacteria from aquaculture effluent and its performance in treating high turbid water. J Water Process Eng 42:102194. https://doi.org/10.1016/j.jwpe.2021.102194CrossRef

10.

Kurniawan SB, Ramli NN, Said NSM et al (2022) Practical limitations of bioaugmentation in treating heavy metal contaminated soil and role of plant growth promoting bacteria in phytoremediation as a promising alternative approach. Heliyon 8:e08995. https://doi.org/10.1016/j.heliyon.2022.e08995CrossRef

11.

Buhari J, Hasan HA, Rahim NFM et al (2022) Unveiling the optimal ammonia-oxidising bacterial consortium for polishing low ammonia-contaminated wastewater. J Water Process Eng 47:102753. https://doi.org/10.1016/j.jwpe.2022.102753CrossRef

12.

Al-Ajalin FAH, Abdullah SRS, Idris M et al (2022) Removal of ammonium, phosphate, and COD by bacteria isolated from Lepironia articulata and Scirpus grossus root system. Int J Environ Sci Technol. https://doi.org/10.1007/s13762-022-03926-1CrossRef

13.

Kurniawan SB, Ahmad A, Said NSM et al (2021) Macrophytes as wastewater treatment agents: nutrient uptake and potential of produced biomass utilization toward circular economy initiatives. Sci Total Environ 790:148219. https://doi.org/10.1016/j.scitotenv.2021.148219CrossRef

14.

Hasan HA, Ezril Hafiz R, Muhamad MH et al (2020) Bioflocculant production using palm oil mill and sago mill effluent as a fermentation feedstock: characterization and mechanism of flocculation. J Environ Manage 260.https://doi.org/10.1016/j.jenvman.2019.110046

15.

Daud NM, Sheikh Abdullah SR, Abu Hasan H (2018) Response surface methodological analysis for the optimization of acid-catalyzed transesterification biodiesel wastewater pre-treatment using coagulation–flocculation process. Process Saf Environ Prot 113:184–192. https://doi.org/10.1016/j.psep.2017.10.006CrossRef

16.

Liu Z, Wei H, Li A, Yang H (2019) Enhanced coagulation of low-turbidity micro-polluted surface water: properties and optimization. J Environ Manage 233:739–747. https://doi.org/10.1016/j.jenvman.2018.08.101CrossRef

17.

Wei H, Gao B, Ren J et al (2018) Coagulation/flocculation in dewatering of sludge: a review. Water Res 143:608–631. https://doi.org/10.1016/j.watres.2018.07.029CrossRef

18.

Mohd-Salleh SNA, Mohd-Zin NS, Othman N (2019) A review of wastewater treatment using natural material and its potential as aid and composite coagulant. Sains Malaysiana 48:155–164CrossRef

19.

Yang R, Li H, Huang M et al (2016) A review on chitosan-based flocculants and their applications in water treatment. Water Res 95:59–89. https://doi.org/10.1016/j.watres.2016.02.068CrossRef

20.

Alnawajha MM, Kurniawan SB, Imron MF et al (2022) Plant-based coagulants/flocculants: characteristics, mechanisms, and possible utilization in treating aquaculture effluent and benefiting from the recovered nutrients. Environ Sci Pollut Res. https://doi.org/10.1007/s11356-022-21631-xCrossRef

21.

Choy SY, Prasad KMN, Wu TY, Ramanan RN (2015) A review on common vegetables and legumes as promising plant-based natural coagulants in water clarification. Int J Environ Sci Technol 12:367–390. https://doi.org/10.1007/s13762-013-0446-2CrossRef

22.

Kurniawan SB, Ahmad A, Imron MF et al (2022) Potential of microalgae cultivation using nutrient-rich wastewater and harvesting performance by biocoagulants/bioflocculants: mechanism, multi-conversion of biomass into valuable products, and future challenges. J Clean Prod 365:132806. https://doi.org/10.1016/j.jclepro.2022.132806CrossRef

23.

Yongabi KAK (2010) Biocoagulants for water and waste water purification: a review. Int Rev Chem Eng 2:444–458

24.

Nasir NM, Mohd Yunos FH, Wan Jusoh HH et al (2019) Advances in water and wastewater treatment harvesting of Chlorella sp. microalgae using Aspergillus niger as bio-flocculant for aquaculture wastewater treatment. J Environ Manage 249. https://doi.org/10.1016/j.jenvman.2019.109373

25.

Kurniawan SB, Imron MF, Sługocki Ł et al (2022) Assessing the effect of multiple variables on the production of bioflocculant by Serratia marcescens: Flocculating activity, kinetics, toxicity, and flocculation mechanism. Sci Total Environ 836:155564. https://doi.org/10.1016/j.scitotenv.2022.155564CrossRef

26.

Ahmad A, Kurniawan SB, Ahmad J et al (2022) Dosage-based application versus ratio-based approach for metal- and plant-based coagulants in wastewater treatment: merits, limitations, and applicability. J Clean Prod 334.https://doi.org/10.1016/j.jclepro.2021.130245

27.

Abd Razak NH, Khairuddin N, Ismail KN, Musa M (2018) Coagulant from Leucaena leucocephala for chromium removal. In: IOP Conference Series: Materials Science and Engineering. IOP Publishing, p 12025

28.

Abu Bakar SNH, Abu Hasan H, Abdullah SRS et al (2021) A review of the production process of bacteria-based polymeric flocculants. J Water Process Eng 40:101915. https://doi.org/10.1016/j.jwpe.2021.101915CrossRef

29.

Kurniawan SB, Abdullah SRS, Imron MF et al (2021) Potential of valuable materials recovery from aquaculture wastewater: an introduction to resource reclamation. Aquac Res. https://doi.org/10.1111/are.15180CrossRef

30.

Kumar V, Othman N, Asharuddin S (2017) Applications of natural coagulants to treat wastewater− a review. In: MATEC Web of Conferences. EDP Sciences, p 6016

31.

Kurniawan SB, Imron MF, Chik CENCE et al (2022) What compound inside biocoagulants/bioflocculants is contributing the most to the coagulation and flocculation processes? Sci Total Environ 806:150902. https://doi.org/10.1016/j.scitotenv.2021.150902CrossRef

32.

Igwegbe CA, Onukwuli OD (2019) Removal of total dissolved solids (TDS) from aquaculture wastewater by coagulation-flocculation process using sesamum indicum extract: effect of operating parameters and coagulation-flocculation kinetics. Pharm Chem J 6:32–45

33.

Luo Y, Gao B, Yue Q, Li R (2018) Application of enteromorpha polysaccharides as coagulant aid in the simultaneous removal of CuO nanoparticles and Cu2+: Effect of humic acid concentration. Chemosphere 204:492–500. https://doi.org/10.1016/j.chemosphere.2018.03.168CrossRef

34.

Ahmad A, Kurniawan SB, Abdullah SRS et al (2021) Exploring the extraction methods for plant-based coagulants and their future approaches. Sci Total Environ. https://doi.org/10.1016/j.scitotenv.2021.151668CrossRef

35.

Ang T-H, Kiatkittipong K, Kiatkittipong W et al (2020) Insight on extraction and characterisation of biopolymers as the green coagulants for microalgae harvesting. Water 12:1388. https://doi.org/10.3390/w12051388CrossRef

36.

Yin CY (2010) Emerging usage of plant-based coagulants for water and wastewater treatment. Process Biochem 45(9):1437–1444CrossRef

37.

Kristianto H, Paulina S, Muliarahayu Soetedjo JN (2018) Exploration of various indonesian indigenous plants as natural coagulants for synthetic turbid water. Int J Technol 9:464–471. https://doi.org/10.14716/ijtech.v9i3.279

38.

Al-Mamun A, Basir ATA (2016) White popinac as potential phyto-coagulant to reduce turbidity of river water. ARPN J Eng Appl Sci 11:7180–7183

39.

Kristanda J, Sintiago KS, Kristianto H et al (2021) Optimization study of leucaena leucocephala seed extract as natural coagulant on decolorization of aqueous congo red solutions. Arab J Sci Eng 46:6275–6286CrossRef

40.

Kristianto H, Rahman H, Prasetyo S, Sugih AK (2019) Removal of Congo red aqueous solution using Leucaena leucocephala seed’s extract as natural coagulant. Appl Water Sci 9.https://doi.org/10.1007/s13201-019-0972-2

41.

Kristianto H, Reynaldi E, Prasetyo S, Sugih AK (2020) Adsorbed leucaena protein on citrate modified Fe3O4 nanoparticles: synthesis, characterization, and its application as magnetic coagulant. Sustain Environ Res 30:1–11CrossRef

42.

Ernest E, Onyeka O, David N, Blessing O (2017) Effects of pH, dosage, temperature and mixing speed on the efficiency of water melon seed in removing the turbidity and colour of Atabong River, Awka-Ibom State, Nigeria. Int J Adv Eng Manag Sci 3:239833

43.

Ahmad A, Abdullah SRS, Hasan HA et al (2021) Plant-based versus metal-based coagulants in aquaculture wastewater treatment: effect of mass ratio and settling time. J Water Process Eng 43:102269. https://doi.org/10.1016/j.jwpe.2021.102269CrossRef

44.

Kadir AA, Abdullah SRS, Othman BA et al (2020) Dual function of Lemna minor and Azolla pinnata as phytoremediator for Palm Oil Mill Effluent and as feedstock. Chemosphere 259:127468. https://doi.org/10.1016/j.chemosphere.2020.127468CrossRef

45.

Bhatti M, Kamboj A, Saluja AK (2013) Spectrophotometric estimation of total polysaccharides in Kalanchoe pinnatum and Kalanchoe crenata. Int J Pharm Pharm Sci 5:40–41

46.

Magalhães ERB, Fonseca de Menezes NN, Silva FL et al (2021) Effect of oil extraction on the composition, structure, and coagulant effect of Moringa oleifera seeds. J Clean Prod 279:123902. https://doi.org/10.1016/j.jclepro.2020.123902CrossRef

47.

Rath BP, Das S, Das MPK, Thatoi H (2014) Optimization of extracellular chromate reductase production by Bacillus amyloliquefaciens (CSB 9) isolated from chromite mine environment. Biocatal Agric Biotechnol 3:35–41CrossRef

48.

Kan C, Huang C, Pan JR (2002) Time requirement for rapid-mixing in coagulation. Colloids Surfaces A Physicochem Eng Asp 203:1–9CrossRef

49.

Kan C, Huang C, Pan JR (2002) Coagulation of high turbidity water: the effects of rapid mixing. J Water Supply Res Technol 51:77–85CrossRef

50.

Ebeling JM, Sibrell PL, Ogden SR, Summerfelt ST (2003) Evaluation of chemical coagulation-flocculation aids for the removal of suspended solids and phosphorus from intensive recirculating aquaculture effluent discharge. Aquac Eng 29:23–42. https://doi.org/10.1016/S0144-8609(03)00029-3CrossRef

51.

Zhang Z, Dan LIU, Dandan HU et al (2013) Effects of slow-mixing on the coagulation performance of polyaluminum chloride (PACI). Chinese J Chem Eng 21:318–323CrossRef

52.

Heiderscheidt E, Tesfamariam A, Pulkkinen J et al (2020) Solids management in freshwater-recirculating aquaculture systems: effectivity of inorganic and organic coagulants and the impact of operating parameters. Sci Total Environ 742.https://doi.org/10.1016/j.scitotenv.2020.140398

53.

Madrona GS, Branco IG, Seolin VJ et al (2012) Evaluation of extracts of Moringa oleifera Lam seeds obtained with NaCl and their effects on water treatment. Acta Sci Technol 34:289–293CrossRef

54.

Abidin ZZ, Ismail N, Yunus R et al (2011) A preliminary study on Jatropha curcas as coagulant in wastewater treatment. Environ Technol 32:971–977. https://doi.org/10.1080/09593330.2010.521955CrossRef

55.

Kurniawan SB, Imron MF, Abdullah SRS et al (2022) Treatment of real aquaculture effluent using bacteria-based bioflocculant produced by Serratia marcescens. J Water Process Eng 47:102708. https://doi.org/10.1016/j.jwpe.2022.102708CrossRef

56.

Muda K, Ali NSA, Abdullah UN, Sahir AB (2020) Potential use of fruit seeds and plant leaves as coagulation agent in water treatment. J Environ Treat Tech 8:971–977

57.

Unnisa SA, Bi SZ (2018) Carica papaya seeds effectiveness as coagulant and solar disinfection in removal of turbidity and coliforms. Appl Water Sci 8.https://doi.org/10.1007/s13201-018-0791-x

58.

Mohd. Radzuan R, Radin Mohamed RMS, Al-Gheethi AA, Mohd. Kassim AH (2017) Application of natural coagulants for wastewater treatment. Integr Water Resour Prot:60–73

59.

Kakoi B, Kaluli JW, Ndiba P, Thiong’o G, (2016) Banana pith as a natural coagulant for polluted river water. Ecol Eng 95:699–705. https://doi.org/10.1016/j.ecoleng.2016.07.001CrossRef

60.

BinAhmed S, Ayoub G, Al-Hindi M, Azizi F (2015) The effect of fast mixing conditions on the coagulation–flocculation process of highly turbid suspensions using liquid bittern coagulant. Desalin Water Treat 53:3388–3396. https://doi.org/10.1080/19443994.2014.933043CrossRef

61.

Birima AH, Ahmed AT, Noor MJMM et al (2015) Application of salt extracted peanut seeds in the pretreatment of palm oil mill effluent (POME). Desalin Water Treat 55:2196–2200. https://doi.org/10.1080/19443994.2014.930696CrossRef

62.

Hoa NT, Hue CT (2018) Enhanced water treatment by moringa oleifera seeds extract as the bio-coagulant: role of the extraction method. J Water Supply Res Technol - AQUA 67:634–647. https://doi.org/10.2166/aqua.2018.070CrossRef

Titel: Effectiveness of using water-extracted Leucaena leucocephala seeds as a coagulant for turbid water treatment: effects of dosage, pH, mixing speed, mixing time, and settling time
verfasst von: Mohammad Mohammad Alnawajha
Siti Rozaimah Sheikh Abdullah
Hassimi Abu Hasan
Ahmad Razi Othman
Setyo Budi Kurniawan
Publikationsdatum: 26.08.2022
Verlag: Springer Berlin Heidelberg
Erschienen in: Biomass Conversion and Biorefinery / Ausgabe 10/2024
Print ISSN: 2190-6815
Elektronische ISSN: 2190-6823
DOI: https://doi.org/10.1007/s13399-022-03233-2

Springer Professional

Abstract

Bitte loggen Sie sich ein, um Zugang zu Ihrer Lizenz zu erhalten.

Sie haben noch keine Lizenz? Dann Informieren Sie sich jetzt über unsere Produkte:

Springer Professional "Wirtschaft+Technik"

Springer Professional "Technik"

Weitere Artikel der Ausgabe 10/2024

Conversion of non-edible Baobab oil as an alternative cooling medium in transformers and practicability analysis of ageing using Euler’s method and artificial neural network

Processing and utilization of an eco-friendly oil as heat transfer fluid derived from camelina seeds

Formulation and application of cashew nutshell liquid derivatives as potential oilfield chemical for crude oil flow assurance

Use of N-Methylmorpholine N-oxide (NMMO) pretreatment to enhance the bioconversion of lignocellulosic residues to methane

Enhanced ultrasonically assisted extraction of bitter melon (Momordica charantia) leaf phenolic compounds using choline chloride-acetic acid–based natural deep eutectic solvent: an optimization approach and in vitro digestion

Effect of ultrasound pretreatment combined with enzymatic hydrolysis of non-conventional starch on sugar yields to bioethanol conversion