nach oben

Cellulose

Erschienen in:

01.08.2008

The effect of barley husk arabinoxylan adsorption on the properties of cellulose fibres

verfasst von: Tobias Köhnke, Carla Pujolras, Johannes P. Roubroeks, Paul Gatenholm

Erschienen in: Cellulose | Ausgabe 4/2008

Einloggen

Aktivieren Sie unsere intelligente Suche, um passende Fachinhalte oder Patente zu finden.

search-config

KI-gestützte Suche

Aus

Abstract

This study investigates the adsorption of (glucurono)arabinoxylan (GAX) on cellulose fibres and the properties thereof. A water-soluble GAX, from barley husks (Hordeum vulgare), was isolated using chlorite delignification and alkaline extraction followed by enzymatic purification. The isolated GAX fraction showed an arabinose to xylose ratio of 0.22 and a weight average molar mass of 20,200 g/mol, as determined by size exclusion chromatography (SEC) in DMSO:H₂O. The GAX was adsorbed on cellulose fibres under well controlled conditions, where temperature and initial concentration of GAX proved to be important parameters in controlling the level of adsorption. The adsorption process was also dependent on xylan molecular structure. Carbohydrate analysis on the modified fibres showed a preferential adsorption of low substituted xylans (arabinose to xylose ratio of ∼0.10). During the adsorption process the GAX solution was analyzed using SEC-RI-MALLS in aqueous solvent, which demonstrated a molecular xylan adsorption on cellulose fibres. Additionally, a decrease in light scattering responses, which corresponds to an adsorption of aggregated xylan and/or xylan with a great tendency towards self-association, could be observed during the adsorption process. This was demonstrated by adsorption of GAX on regenerated cellulose fibres (Lyocell), which compared to native fibres possesses a relatively smooth fibre surface. Atomic force microscopy analysis visualised a heterogeneous decoration of the Lyocell fibres with xylan agglomerates. The effect of GAX adsorption on paper strength was also investigated. A GAX modified kraft pulp showed an evident increase in tensile strength, which might be due to a retained fibre–fibre bonding ability for xylan coated fibrils after drying and rewetting.

Vorheriger Artikel Characteristics of thin cellulose ester films spin-coated from acetone and ethyl acetate solutions

Nächster Artikel The residual amide content of cellulose sequentially solvent-exchanged and then vacuum-dried

Sie haben noch keine Lizenz? Dann Informieren Sie sich jetzt über unsere Produkte:

Springer Professional "Technik"

Online-Abonnement

Mit Springer Professional "Technik" erhalten Sie Zugriff auf:

über 67.000 Bücher
über 390 Zeitschriften

aus folgenden Fachgebieten:

Automobil + Motoren
Bauwesen + Immobilien
Business IT + Informatik
Elektrotechnik + Elektronik
Energie + Nachhaltigkeit
Maschinenbau + Werkstoffe

Jetzt Wissensvorsprung sichern!

Jetzt informieren

Springer Professional "Wirtschaft+Technik"

Online-Abonnement

Mit Springer Professional "Wirtschaft+Technik" erhalten Sie Zugriff auf:

über 102.000 Bücher
über 537 Zeitschriften

aus folgenden Fachgebieten:

Automobil + Motoren
Bauwesen + Immobilien
Business IT + Informatik
Elektrotechnik + Elektronik
Energie + Nachhaltigkeit
Finance + Banking
Management + Führung
Marketing + Vertrieb
Maschinenbau + Werkstoffe
Versicherung + Risiko

Jetzt Wissensvorsprung sichern!

Jetzt informieren

Andrewartha KA, Phillips RD, Stone BA (1979) Solution properties of wheat-flour arabinoxylans and enzymically modified arabinoxylans. Carbohydr Res 77:191–204CrossRef

Aspinall GO, Ferrier RJ (1957) The constitution of barley husk hemicellulose. J Chem Soc 840:4188–4194CrossRef

Blake JD, Richards GN (1971) Evidence for molecular aggregation in hemicelluloses. Carbohydr Res 18:11–21CrossRef

Brumer H III, Zhou Q, Baumann MJ, Carlsson K, Teeri TT (2004) Activation of crystalline cellulose surfaces through the chemoenzymatic modification of xyloglucans. J Am Chem Soc 126(18):5715–5721CrossRef

Christiernin M, Henriksson G, Lindström ME, Brumer H, Teeri TT, Lindström T, Laine J (2003) The effects of xyloglucan on the properties of paper made from bleached kraft pulp. Nord Pulp Paper Res J 18(2):182–187CrossRef

Dea ICM, Rees DA, Beveridge RJ, Richards GN (1973) Aggregation with change of conformation in solutions of hemicellulose xylans. Carbohydr Res 29:363–372CrossRef

Duchesne I, Hult EL, Molin U, Daniel G, Iversen T, Lennholm H (2001) The influence of hemicellulose on fibril aggregation of kraft pulp fibres as revealed by FE-SEM and CP/MAS ¹³C-NMR. Cellulose 8(2):103–111CrossRef

Ebringerova A, Hromadkova Z, Burchard W, Dolega R, Vorwerg W (1994) Solution properties of water-insoluble rye-bran arabinoxylan. Carbohydr Polym 24:161–169CrossRef

Esker A, Becker U, Jamin S, Beppu S, Renneckar S, Glasser W (2004) Self-assembly behavior of some co- and heteropolysaccharides related to hemicelluloses. In: Gatenholm P, Tenkanen M (eds) Hemicelluloses: science and technology. ACS Symp Ser 864:198–219

Evans DF, Wennerström H (1999) The colloidal domain. Wiley-VCH, Toronto, pp 351–400

Glasser WG, Kaar WE, Jain RK, Sealey JE (2000) Isolation options for non-cellulosic heteropolysaccharides (HetPS). Cellulose 7(3):299–317CrossRef

Gradwell SE, Renneckar S, Esker AR, Heinze T, Gatenholm P, Vaca-Garcia C, Glasser W (2004) Surface modification of cellulose fibers: towards wood composites by biomimetics. C R Biol 327:945–953CrossRef

Gross RA, Kalra B (2002) Biodegradable polymers for the environment. Science 297:803–807CrossRef

Hannuksela T, Tenkanen M, Holmbom B (2002) Sorption of dissolved galactoglucomannans and galactomannans to bleached kraft pulp. Cellulose 9(3/4):251–261CrossRef

Hannuksela T, Holmbom B, Mortha G, Lachenal D (2004) Effect of sorbed galactoglucomannans and galactomannans on pulp and paper handsheet properties, especially strength properties. Nord Pulp Paper Res J 19(2):237–244CrossRef

Hansson J-Å (1970) Sorption of hemicelluloses on cellulose fibres. Part 3. The temperature dependence on sorption of birch xylan and pine glucomannan at kraft pulping conditions. Svensk Papperstid 73(3):49–53

Hartler N, Lund A (1962) Sorption of xylans on cotton. Svensk Papperstidn 65(23):951–955

Henriksson Å, Gatenholm P (2001) Controlled assembly of glucuronoxylans onto cellulose fibres. Holzforschung 55(5):494–502CrossRef

Henriksson Å, Gatenholm P (2002) Surface properties of CTMP fibers modified with xylans. Cellulose 9(1):55–64CrossRef

Höije A, Gröndahl M, Tommeraas K, Gatenholm P (2005) Isolation and characterization of physicochemical and material properties of arabinoxylans from barley husks. Carbohydr Polym 61:266–275CrossRef

Höije A, Sandström C, Roubroeks JP, Andersson R, Gohil S, Gatenholm P (2006) Evidence of the presence of 2-O-β-d-xylopyranosyl-α-l-arabinofuranose side chains in barley husk arabinoxylan. Carbohydr Res 341:2959–2966CrossRef

Kabel MS, van den Borne H, Vincken JP, Voragen AGJ, Schols HA (2007) Structural differences of xylans affect their interaction with cellulose. Carbohydr Polym 69(1):94–105CrossRef

Köhnke T, Gatenholm P (2007) The effect of controlled glucuronoxylan adsorption on drying-induced strength loss of bleached softwood pulp. Nordic Pulp Paper Res J 22(4):508–515CrossRef

LeBel RG, Goring DA, Timell TE (1963) Solution properties of birch xylan. I. Measurement of molecular weight. J Polym Sci Part C 2:9–28CrossRef

Lima DU, Oliveira RC, Buckeridge MS (2003) Seed storage hemicelluloses as wet-end additives in papermaking. Carbohydr Polym 52(4):367–373CrossRef

Lima DU, Loh W, Buckeridge MS (2004) Xyloglucan-cellulose interaction depends on the sidechains and molecular weight of xyloglucans. Plant Physiol Biochem 42(5):389–394CrossRef

Linder Å, Gatenholm P (2004) Effect of cellulose substrate on assembly of xylans. In: Gatenholm P, Tenkanen M (eds) Hemicelluloses: science and technology. ACS Symp Ser 864:236–253

Linder Å, Bergman R, Bodin A, Gatenholm P (2003) Mechanism of assembly of xylan onto cellulose surfaces. Langmuir 19(12):5072–5077CrossRef

Lindström T, Wågberg L, Larsson PT (2005) On the nature of joint strength in paper—a review of dry and wet strength resins used in paper manufacturing. In: I’Anson SJ (ed) Adv Paper Sci Technol. Trans 13th Fund Res Symp, Cambridge, UK, pp 457–562

McNeil M, Albersheim P, Taiz L, Jones RL (1975) The structure of plant cell walls. VII. Barley aleurone cells. Plant Physiol 55(1):64–68CrossRef

Oksanen T, Buchert J, Viikari L (1997) The role of hemicelluloses in the hornification of bleached kraft pulps. Holzforschung 51(4):355–360CrossRef

Paananen A, Österberg M, Rutland M, Tammelin T, Saarinen T, Tappura K, Stenius P (2004) Interaction between cellulose and xylan: an atomic force microscope and quartz crystal microbalance study. In: Gatenholm P, Tenkanen M (eds) Hemicelluloses: science and technology. ACS Symp Ser 864:269–290

Puls J, Schröder N, Stein A, Janzon R, Saake B (2006) Xylans from oat spelts and birch kraft pulp. In: Fischer K, Heinze T (eds) Hemicelluloses. Macromol Symp 232:85–92

Ragauskas AJ, Williams CK, Davison BH, Britovsek G, Cairney J, Eckert CA, Frederick WJ Jr, Hallet JP, Leak DJ, Liotta CL, Mielenz JR, Murphy R, Templer R, Tschaplinski T (2006) The path forward for biofuels and biomaterials. Science 311:484–489CrossRef

Sarkanen KV, Ludwig CH (1971) Lignins. Occurrence, formation, structure and reactions. Wiley-Interscience, New York, pp 193–194

Saake B, Kruse Th, Puls J (2001) Investigation on molar mass, solubility and enzymatic fragmentation of xylans by multi-detected SEC chromatography. Bioresour Technol 80:195–204CrossRef

Schönberg C, Oksanen T, Suurnäkki A, Kettunen H, Buchert J (2001) The importance of xylan for the strength properties of spruce kraft pulp fibre. Holzforschung 55(6):639–644CrossRef

Suurnäkki A, Oksanen T, Kettunen H, Buchert J (2003) The effect of mannan on physical properties of ECF bleached softwood kraft fibre handsheets. Nord Pulp Paper Res J 18(4):429–435CrossRef

Teeri TT, Brumer H III, Daniel G, Gatenholm P (2007) Biomimetic engineering of cellulose-based materials. Trends Biotechnol 25(7):299–306CrossRef

Theander O, Westerlund EA (1986) Studies on dietary fiber. 3. Improved procedures for analysis of dietary fiber. J Agric Food Chem 34(2):330–336CrossRef

Theander O, Åman P, Westerlund E, Andersson R, Pettersson D (1995) Total dietary fiber determined as neutral sugar residues, uronic acid residues, and Klason lignin (The Uppsala method): collaborative study. J AOAC Int 78(4):1030–1044

van Wyk JPH (2001) Biotechnology and the utilization of biowaste as a resource for bioproduct development. Trends Biotechnol 19(5):172–177CrossRef

Westbye P, Köhnke T, Glasser W, Gatenholm P (2007) The influence of lignin on the self-assembly behaviour of xylan rich fractions from birch (Betula pendula). Cellulose 14(6):603–613CrossRef

Westbye P, Köhnke T, Gatenholm P (2008) Fractionation and characterization of xylan rich extracts from birch. Holzforschung 62(1):31–37CrossRef

Titel: The effect of barley husk arabinoxylan adsorption on the properties of cellulose fibres
verfasst von: Tobias Köhnke
Carla Pujolras
Johannes P. Roubroeks
Paul Gatenholm
Publikationsdatum: 01.08.2008
Verlag: Springer Netherlands
Erschienen in: Cellulose / Ausgabe 4/2008
Print ISSN: 0969-0239
Elektronische ISSN: 1572-882X
DOI: https://doi.org/10.1007/s10570-008-9209-5

Springer Professional

Abstract

Bitte loggen Sie sich ein, um Zugang zu Ihrer Lizenz zu erhalten.

Sie haben noch keine Lizenz? Dann Informieren Sie sich jetzt über unsere Produkte:

Springer Professional "Technik"

Springer Professional "Wirtschaft+Technik"

Weitere Artikel der Ausgabe 4/2008

Graft polymerization of vinyl monomers onto cotton fibres pretreated with amines

An estimation of the Young’s modulus of bacterial cellulose filaments

Synthesis of a novel antimicrobial-modified starch and its adsorption on cellulose fibers: part II––adsorption behaviors of cationic starch on cellulose fibers

Characteristics of thin cellulose ester films spin-coated from acetone and ethyl acetate solutions

The residual amide content of cellulose sequentially solvent-exchanged and then vacuum-dried

Preparation of novel antimicrobial-modified starch and its adsorption on cellulose fibers: Part I. Optimization of synthetic conditions and antimicrobial activities