nach oben

Erschienen in:

21.11.2020 | Original Article

Phosphorus recovery by struvite from anaerobic co-digestion effluents during residual biomass treatment

verfasst von: Carolina Ochoa, Mario A. Hernández, Olga L. Bayona, Hernando A. Camargo, Iván O. Cabeza, Angélica M. Candela

Erschienen in: Biomass Conversion and Biorefinery | Ausgabe 2/2021

Einloggen

Aktivieren Sie unsere intelligente Suche, um passende Fachinhalte oder Patente zu finden.

search-config

KI-gestützte Suche

Aus

Abstract

The residual biomass from agricultural activities has macronutrients and micronutrients, which could be recovered after an anaerobic co-digestion process. In this study, the effluents of the anaerobic co-digestion, which use coffee, cocoa mucilage, and pig manure, were evaluated to produce struvite. The effects of the Ca²⁺/PO₄³⁻ ratio on the purity of struvite precipitation from synthetic and anaerobic co-digestion effluents was evaluated. The influence of pH, Ca²⁺/PO₄³⁻ ration, and stirring speed on the efficiency of PO₄³⁻ recovery and the removal of Ca²⁺ was studied. The phosphorus recovery increased from 85 to 99% with pH change from 8.5 to 10. The lowest removal of Ca²⁺ was 6.6% in the anaerobic effluent with the a ratio Ca²⁺/PO₄³⁻ of 0.3:1 at pH 10. Struvite precipitate with high purity was obtained when the molar ratio was less than 0.3:1, and the pH was fixed to 10. X-ray diffraction analysis and scanning electron microscopy (SEM) confirmed the orthorhombic phases and morphology typical of struvite, respectively. In addition, the presence of K as a macronutrient and Ca and Na as micronutrients increases the viability of the struvite as fertilizer. The high recovery of phosphorus as struvite indicates it could be an alternative for nutrient recovery and utilization of these effluents.

Vorheriger Artikel The role of emulsification as pre-treatment on the anaerobic digestion of oleic acid: process performance, modeling, and sludge metabolic properties

Nächster Artikel Technical feasibility of reforming anaerobic digestion and landfill biogas streams into bio-hydrogen

Sie haben noch keine Lizenz? Dann Informieren Sie sich jetzt über unsere Produkte:

Springer Professional "Wirtschaft+Technik"

Online-Abonnement

Mit Springer Professional "Wirtschaft+Technik" erhalten Sie Zugriff auf:

über 102.000 Bücher
über 537 Zeitschriften

aus folgenden Fachgebieten:

Automobil + Motoren
Bauwesen + Immobilien
Business IT + Informatik
Elektrotechnik + Elektronik
Energie + Nachhaltigkeit
Finance + Banking
Management + Führung
Marketing + Vertrieb
Maschinenbau + Werkstoffe
Versicherung + Risiko

Jetzt Wissensvorsprung sichern!

Jetzt informieren

Springer Professional "Technik"

Online-Abonnement

Mit Springer Professional "Technik" erhalten Sie Zugriff auf:

über 67.000 Bücher
über 390 Zeitschriften

aus folgenden Fachgebieten:

Automobil + Motoren
Bauwesen + Immobilien
Business IT + Informatik
Elektrotechnik + Elektronik
Energie + Nachhaltigkeit
Maschinenbau + Werkstoffe

Jetzt Wissensvorsprung sichern!

Jetzt informieren

EPA (2018) Livestock anaerobic digester database. In: Livest. Anaerob. Dig. Database. https://www.epa.gov/agstar/livestock-anaerobic-digester-database. Accessed 28 Aug 2018

Moerman W, Carballa M, Vandekerckhove A, Derycke D, Verstraete W (2009) Phosphate removal in agro-industry: pilot- and full-scale operational considerations of struvite crystallization. Water Res 43:1887–1892. https://doi.org/10.1016/J.WATRES.2009.02.007CrossRef

Tao W, Fattah KP, Huchzermeier MP (2016) Struvite recovery from anaerobically digested dairy manure: a review of application potential and hindrances. J Environ Manag 169:46–57. https://doi.org/10.1016/J.JENVMAN.2015.12.006CrossRef

Cordell D, Rosemarin A, Schröder JJ, Smit AL (2011) Towards global phosphorus security: a systems framework for phosphorus recovery and reuse options. Chemosphere 84:747–758. https://doi.org/10.1016/j.chemosphere.2011.02.032CrossRef

Zhou X, Li Z, Zheng T, Yan Y, Li P, Odey EA, Mang HP, Uddin SMN (2018) Review of global sanitation development. Environ Int 120:246–261. https://doi.org/10.1016/J.ENVINT.2018.07.047CrossRef

FAO (2017) World fertilizer trends and outlook to 2020

Cherkasov N, Ibhadon AO, Fitzpatrick P (2015) A review of the existing and alternative methods for greener nitrogen fixation. Chem Eng Process Process Intensif 90:24–33. https://doi.org/10.1016/j.cep.2015.02.004CrossRef

Pan B, Lam SK, Mosier A, Luo Y, Chen D (2016) Ammonia volatilization from synthetic fertilizers and its mitigation strategies: a global synthesis. Agric Ecosyst Environ 232:283–289. https://doi.org/10.1016/J.AGEE.2016.08.019CrossRef

Chen D, Suter H, Islam A, Edis R, Freney JR, Walker CN (2008) Prospects of improving efficiency of fertiliser nitrogen in Australian agriculture: a review of enhanced efficiency fertilisers. Soil Res 46:289. https://doi.org/10.1071/SR07197CrossRef

10.

Saha BK, Rose MT, Wong VNL, Cavagnaro TR, Patti AF (2019) A slow release brown coal-urea fertiliser reduced gaseous N loss from soil and increased silver beet yield and N uptake. Sci Total Environ 649:793–800. https://doi.org/10.1016/j.scitotenv.2018.08.145CrossRef

11.

Jaffer Y, Clark T, Pearce P, Parsons S (2002) Potential phosphorus recovery by struvite formation. Water Res 36:1834–1842. https://doi.org/10.1016/S0043-1354(01)00391-8CrossRef

12.

Le Corre KS, Valsami-Jones E, Hobbs P, Parsons SA (2009) Phosphorus recovery from wastewater by struvite crystallization: a review. Crit Rev Environ Sci Technol 39:433–477. https://doi.org/10.1080/10643380701640573CrossRef

13.

Liu Y, Kwag J-H, Kim J-H, Ra C (2011) Recovery of nitrogen and phosphorus by struvite crystallization from swine wastewater. Desalination 277:364–369. https://doi.org/10.1016/J.DESAL.2011.04.056CrossRef

14.

Kataki S, West H, Clarke M, Baruah DC (2016) Phosphorus recovery as struvite: recent concerns for use of seed, alternative mg source, nitrogen conservation and fertilizer potential. Resour Conserv Recycl 107:142–156. https://doi.org/10.1016/J.resconrec.2015.12.009CrossRef

15.

Uludag-Demirer S, Demirer GN, Frear C, Chen S (2008) Anaerobic digestion of dairy manure with enhanced ammonia removal. J Environ Manag 86:193–200. https://doi.org/10.1016/J.JENVMAN.2006.12.002CrossRef

16.

Pastor L, Mangin D, Ferrer J, Seco A (2010) Struvite formation from the supernatants of an anaerobic digestion pilot plant. Bioresour Technol 101:118–125. https://doi.org/10.1016/j.biostech.2009.08.002CrossRef

17.

Türker M, Çelen I (2007) Removal of ammonia as struvite from anaerobic digester effluents and recycling of magnesium and phosphate. Bioresour Technol 98:1529–1534. https://doi.org/10.1016/J.BIORTECH.2006.06.026CrossRef

18.

Ye Z, Shen Y, Ye X, Zhang Z, Chen S, Shi J (2014) Phosphorus recovery from wastewater by struvite crystallization: property of aggregates. J Environ Sci 26:991–1000. https://doi.org/10.1016/S1001-0742(13)60536-7CrossRef

19.

Escudero A, Blanco F, Lacalle A, Pinto M (2015) Struvite precipitation for ammonium removal from anaerobically treated effluents. J Environ Chem Eng 3:413–419. https://doi.org/10.1016/J.jece.2015.01.004CrossRef

20.

Song Y-H, Qiu G-L, Yuan P, Cui XY, Peng JF, Zeng P, Duan L, Xiang LC, Qian F (2011) Nutrients removal and recovery from anaerobically digested swine wastewater by struvite crystallization without chemical additions. J Hazard Mater 190:140–149. https://doi.org/10.1016/J.JHAZMAT.2011.03.015CrossRef

21.

Muhmood A, Wu S, Lu J, Ajmal Z, Luo H, Dong R (2018) Nutrient recovery from anaerobically digested chicken slurry via struvite: performance optimization and interactions with heavy metals and pathogens. Sci Total Environ 635:1–9. https://doi.org/10.1016/j.scitotenv.2018.04.129CrossRef

22.

Shashvatt U, Benoit J, Aris H, Blaney L (2018) CO2-assisted phosphorus extraction from poultry litter and selective recovery of struvite and potassium struvite. Water Res 143:19–27. https://doi.org/10.1016/j.watres.2018.06.035CrossRef

23.

Barbosa SG, Peixoto L, Meulman B, Alves MM, Pereira MA (2016) A design of experiments to assess phosphorous removal and crystal properties in struvite precipitation of source separated urine using different mg sources. Chem Eng J 298:146–153. https://doi.org/10.1016/j.cej.2016.03.148CrossRef

24.

Taddeo R, Honkanen M, Kolppo K, Lepistö R (2018) Nutrient management via struvite precipitation and recovery from various agroindustrial wastewaters: process feasibility and struvite quality. J Environ Manag 212:433–439. https://doi.org/10.1016/j.jenvman.2018.02.027CrossRef

25.

Ronteltap M, Maurer M, Gujer W (2007) Struvite precipitation thermodynamics in source-separated urine. Water Res 41:977–984. https://doi.org/10.1016/j.watres.2006.11.046CrossRef

26.

Taddeo R, Kolppo K, Lepistö R (2016) Sustainable nutrients recovery and recycling by optimizing the chemical addition sequence for struvite precipitation from raw swine slurries. J Environ Manag 180:52–58. https://doi.org/10.1016/j.jenvman.2016.05.009CrossRef

27.

Stolzenburg P, Capdevielle A, Teychené S (2015) Struvite precipitation with MgO as a precursor: application to wastewater treatment. Chem Eng Sci 133:9–15. https://doi.org/10.1016/J.CES.2015.03.008CrossRef

28.

Xia P, Wang X, Wang X, Song J, Wang H, Zhang J, Zhao J (2016) Struvite crystallization combined adsorption of phosphate and ammonium from aqueous solutions by mesoporous MgO□loaded diatomite. Colloids Surfaces A Physicochem Eng Asp 506:220–227. https://doi.org/10.1016/J.COLSURFA.2016.05.101CrossRef

29.

Chai L, Peng C, Min X et al (2017) Two-sectional struvite formation process for enhanced treatment of copper–ammonia complex wastewater. Trans Nonferrous Met Soc China 27:457–466. https://doi.org/10.1016/S1003-6326(17)60052-9CrossRef

30.

Stratful I, Scrimshaw M, Lester J (2001) Conditions influencing the precipitation of magnesium ammonium phosphate. Water Res 35:4191–4199. https://doi.org/10.1016/S0043-1354(01)00143-9CrossRef

31.

Jin Y, Hu Z, Wen Z (2009) Enhancing anaerobic digestibility and phosphorus recovery of dairy manure through microwave-based thermochemical pretreatment. Water Res 43:3493–3502. https://doi.org/10.1016/j.watres.2009.05.017CrossRef

32.

Su C-C, Abarca RRM, de Luna MDG, Lu M-C (2014) Phosphate recovery from fluidized-bed wastewater by struvite crystallization technology. J Taiwan Inst Chem Eng 45:2395–2402. https://doi.org/10.1016/j.jtice.2014.04.002CrossRef

33.

Shih Y-J, Abarca RRM, de Luna MDG, Huang YH, Lu MC (2017) Recovery of phosphorus from synthetic wastewaters by struvite crystallization in a fluidized-bed reactor: effects of pH, phosphate concentration and coexisting ions. Chemosphere 173:466–473. https://doi.org/10.1016/j.chemosphere.2017.01.088CrossRef

34.

Bayuseno AP, Schmahl WW (2020) Crystallization of struvite in a hydrothermal solution with and without calcium and carbonate ions. Chemosphere 250:126245. https://doi.org/10.1016/j.chemosphere.2020.126245CrossRef

35.

Le Corre KS, Valsami-Jones E, Hobbs P, Parsons SA (2005) Impact of calcium on struvite crystal size, shape and purity. J Cryst Growth 283:514–522. https://doi.org/10.1016/j.jcrysgro.2005.06.012CrossRef

36.

Liu X, Wang J (2019) Impact of calcium on struvite crystallization in the wastewater and its competition with magnesium. Chem Eng J 378:122121. https://doi.org/10.1016/j.cej.2019.122121CrossRef

37.

Ferguson JF, McCarty PL (1971) Effects of carbonate and magnesium on calcium phosphate precipitation. Environ Sci Technol 5:534–540. https://doi.org/10.1021/es60053a005CrossRef

38.

Huchzermeier MP, Tao W (2012) Overcoming challenges to Struvite recovery from anaerobically digested dairy manure. Water Environ Res 84:34–41. https://doi.org/10.2175/106143011X13183708018887CrossRef

39.

Huang H, Yang J, Li D (2014) Recovery and removal of ammonia–nitrogen and phosphate from swine wastewater by internal recycling of struvite chlorination product. Bioresour Technol 172:253–259. https://doi.org/10.1016/j.biortech.2014.09.024CrossRef

40.

Zhao T-L, Li H, Huang Y-R, Yao QZ, Huang Y, Zhou GT (2019) Microbial mineralization of struvite: salinity effect and its implication for phosphorus removal and recovery. Chem Eng J 358:1324–1331. https://doi.org/10.1016/j.cej.2018.10.139CrossRef

41.

Münch EV, Barr K (2001) Controlled struvite crystallisation for removing phosphorus from anaerobic digester sidestreams. Water Res 35:151–159. https://doi.org/10.1016/S0043-1354(00)00236-0CrossRef

42.

APHA (1998) Standard methods for the examination of water and wastewater. American Public Health Association / American Water Works Association / Water Environment Federation, Washington DC

43.

Muhmood A, Lu J, Dong R, Wu S (2019) Formation of struvite from agricultural wastewaters and its reuse on farmlands: status and hindrances to closing the nutrient loop. J Environ Manag 230:1–13. https://doi.org/10.1016/j.jenvman.2018.09.030CrossRef

44.

Huang HM, Xiao XM, Yang LP, Yan B (2011) Removal of ammonium from rare-earth wastewater using natural brucite as a magnesium source of struvite precipitation. Water Sci Technol 63:468–474. https://doi.org/10.2166/wst.2011.245CrossRef

45.

Zhang H, Gong W, Luo X, Xie B, Li G, Liang H (2019) Obtaining high-purity struvite from anaerobically digested wastewater: effects of pH, mg/P, and Ca 2+ interactions. Environ Eng Sci 36:102–113. https://doi.org/10.1089/ees.2018.0065CrossRef

46.

Rahman MM, Salleh MAM, Rashid U, Ahsan A, Hossain MM, Ra CS (2014) Production of slow release crystal fertilizer from wastewaters through struvite crystallization – a review. Arab J Chem 7:139–155. https://doi.org/10.1016/j.arabjc.2013.10.007CrossRef

47.

Shu J, Wu H, Chen M, Peng H, Li B, Liu R, Liu Z, Wang B, Huang T, Hu Z (2019) Fractional removal of manganese and ammonia nitrogen from electrolytic metal manganese residue leachate using carbonate and struvite precipitation. Water Res 153:229–238. https://doi.org/10.1016/j.watres.2018.12.044CrossRef

48.

Wilsenach JA, Schuurbiers CAH, van Loosdrecht MCM (2007) Phosphate and potassium recovery from source separated urine through struvite precipitation. Water Res 41:458–466. https://doi.org/10.1016/j.watres.2006.10.014CrossRef

49.

Ronteltap M, Maurer M, Hausherr R, Gujer W (2010) Struvite precipitation from urine – influencing factors on particle size. Water Res 44:2038–2046. https://doi.org/10.1016/j.watres.2009.12.015CrossRef

50.

Luo Y, Li H, Huang Y-R, Zhao TL, Yao QZ, Fu SQ, Zhou GT (2018) Bacterial mineralization of struvite using MgO as magnesium source and its potential for nutrient recovery. Chem Eng J 351:195–202. https://doi.org/10.1016/J.CEJ.2018.06.106CrossRef

51.

Polat S, Sayan P (2019) Application of response surface methodology with a Box–Behnken design for struvite precipitation. Adv Powder Technol 30:2396–2407. https://doi.org/10.1016/j.apt.2019.07.022CrossRef

Titel: Phosphorus recovery by struvite from anaerobic co-digestion effluents during residual biomass treatment
verfasst von: Carolina Ochoa
Mario A. Hernández
Olga L. Bayona
Hernando A. Camargo
Iván O. Cabeza
Angélica M. Candela
Publikationsdatum: 21.11.2020
Verlag: Springer Berlin Heidelberg
Erschienen in: Biomass Conversion and Biorefinery / Ausgabe 2/2021
Print ISSN: 2190-6815
Elektronische ISSN: 2190-6823
DOI: https://doi.org/10.1007/s13399-020-01146-6

Springer Professional

Abstract

Bitte loggen Sie sich ein, um Zugang zu Ihrer Lizenz zu erhalten.

Sie haben noch keine Lizenz? Dann Informieren Sie sich jetzt über unsere Produkte:

Springer Professional "Wirtschaft+Technik"

Springer Professional "Technik"

Weitere Artikel der Ausgabe 2/2021

A short review of green extraction technologies for rice bran oil

Biomass valorization and phytoremediation as integrated Technology for Municipal Solid Waste Management for developing economic context

Effect of pretreatment techniques on enzymatic hydrolysis of food waste

Nutrient recycling: from waste to crop

Bioremediation of hexavalent chromium-contaminated wastewater by Bacillus thuringiensis and Staphylococcus capitis isolated from tannery sediment

Biochar production from sewage sludge and microalgae mixtures: properties, sustainability and possible role in circular economy